26V19100003/26/2026
ABC BUS Inc is recalling certain 1999-2013 Van Hool C2045, 2004-2013 Van Hool T2145, 2013-2022 Van Hool TX45, 2013-2023 Van Hool CX45, and 2016-2022 Van Hool CX35 vehicles. The front entrance door may have the incorrect glaze on the lower curb view window. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 205, "Glazing Materials."
Model years in this history: 2013, 2012, 2011, 2010, 2009, 2008, 2007, 2006, 2005, 2004
Consequence and remedy
Consequence
The incorrect glaze may reduce the driver's visibility, increasing the risk of a crash.
Remedy
Dealers will inspect and install a nontransparent vinyl cover over the window as necessary, free of charge. Owner notification letters were mailed April 20, 2026. Owners may contact ABC Bus customer service at 1-877-427-7278. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning April 30, 2026.
21V79900010/14/2021
Van Hool N.V. (Van Hool) is recalling certain 2000-2014 C2045, 2016 CX45, and 1998-2013 T2145 vehicles equipped with Ricon Baylift Wheelchair Lifts. When the lift's outer barrier is fully deployed, it may not withstand a sufficient amount of force, which could cause it to fail. As such, these lifts fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 403, "Platform Lift Systems."
Model years in this history: 2013, 2012, 2011, 2010, 2009, 2008, 2007, 2006, 2005, 2004, 2003, 2002, 2001, 2000, 1999, 1998
Consequence and remedy
Consequence
In the event that a mobility device pushes into the outer barrier, the barrier may fail, increasing the risk of injury for the lift occupant.
Remedy
Ricon will reinforce the outer barrier with additional supports, free of charge. Owner notification letters were mailed on November 30, 2021. Owners may contact Van Hool's customer service at 1-877-427-7278 or 1-407-656-7977. Van Hool's number for this recall is P1528-SB2067.
17V06400001/31/2017
Van Hool N.V. (Van Hool) is recalling certain 2010-2014 C2045 and T2145 motorcoaches, 2014-2015 TX40 motorcoaches, 2014-2017 TX45 motorcoaches, 2011-2015 TD925 motorcoaches, 2014-2016 CX45 motorcoaches and 2010-2013 T2140 motorcoaches. When the vehicle is started in low temperatures, the steering wheel may be difficult to turn.
Model years in this history: 2014, 2013, 2012, 2011, 2010
Consequence and remedy
Consequence
Reduced steering ability can increase the risk of a crash.
Remedy
Van Hool will notify owners, and dealers will replace the steering box, free of charge. The recall began on February 21, 2017. Owners may contact ABC Bus, Inc. at 1-877-427-7278. Van Hool's number for this recall is P826.
16V85700011/29/2016
Van Hool N.V. (Van Hool) is recalling certain model year 2010-2014 C2045 and T2145; 2010 C3045; 2016 CX35; 2014-2016 CX45 and TX45; 2009-2016 TD925; 2015-2016 TDX25 and TX40 and 2010-2013 T2140 motorcoaches. In the affected vehicles, the front steering knuckle carriers may crack.
Model years in this history: 2014, 2013, 2012, 2011, 2010
Consequence and remedy
Consequence
Cracking of a steering knuckle carrier may result in its total failure, allowing a wheel to separate from the vehicle, increasing the risk of a crash.
Remedy
Van Hool will notify owners, and dealers will replace the steering knuckle carriers that were produced from August 2009 through March 2011. Carriers that were produced from April 2011 to December 2014 will be inspected by ultrasonic measurement and replaced as necessary. These repairs will be performed free of charge. The recall began on January 19, 2017. Owners may contact ABC Bus, Inc. at 1-877-427-7278. Van Hool's number for this recall is P855. Note: This recall expands recalls 14V-569 and 15V-331.
16V14400003/09/2016
Van Hool N.V. (Van Hool) is recalling certain model year 2012 A300L, 2011 C2045, 2011-2013 T2145, 2012-2015 TD925, 2016 TDX25, and 2014-2015 TX45 motor coaches equipped with certain Recaro Ergo-M Commercial Bus Driver Seats. The affected seats have J-Brackets that may be missing welds which could allow the seat belt anchorage assembly to separate from the J-Bracket.
Model years in this history: 2013, 2012, 2011
Consequence and remedy
Consequence
If the seatbelt anchorage assembly separates from the J-Bracket, the bus driver may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy
Van Hool will notify owners, and dealers for the manufacturer of the seat will inspect the seats to determine if welds are missing. Any J-Bracket that is missing welds will be removed and replaced, free of charge. The recall began on May 25, 2016. Van Hool's recall number for this campaign is P814-SB1354.
12V49500010/12/2012
Van Hool is recalling certain model year 2011 and 2012 C2045, and model year 2011 T2140 and T2145 motorcoaches manufactured from September 2010 through September 2011, equipped with a Daimler DD13 engine without ground cables installed on the Prestolite AC172 alternators. Internal corrosion may cause the alternator components to overheat.
Model years in this history: 2011
Consequence and remedy
Consequence
If the alternator overheats, the components may melt, possibly resulting in smoke and creating the potential risk of a vehicle fire.
Remedy
Van Hool through their US agent, ABC Bus, Inc., will notify owners, and dealers will add external ground cables to the alternators, free of charge. The safety recall began on December 5, 2012. Owners may contact the warranty administrator for ABC Bus, Inc. toll free at 1-877-427-7278.
12V28600006/21/2012
VAN HOOL IS RECALLING CERTAIN MODEL YEAR 2011-2012 C2045, T2140, AND T2145 VEHICLES, EQUIPPED WITH A DETROIT DIESEL DD13 ENGINE. THE PUMP TO RAIL HIGH PRESSURE FUEL LINE SUPPORT SYSTEM USED ON THESE ENGINES IS SENSITIVE TO ASSEMBLY TORQUE AND MAY BE DAMAGED DURING SERVICE WORK. AS A RESULT OF OTHER REPAIRS, THE LINE SUPPORTS MAY LOOSEN, POTENTIALLY LEADING TO FUEL LINE CRACKING AND A FUEL LEAK.
Model years in this history: 2012, 2011
Consequence and remedy
Consequence
A FUEL LEAK COULD CREATE A ROAD HAZARD, INCREASING THE RISK OF A CRASH. ALSO A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy
VAN HOOL IS WORKING WITH DAIMLER TRUCKS NORTH AMERICA TO REPAIR THESE MOTORCOACHES (PLEASE SEE 12E009000). WHERE NECESSARY, THE HIGH PRESSURE FUEL LINE SUPPORT SYSTEM WILL BE REPLACED BY DTNA AUTHORIZED SERVICE FACILITIES, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 15, 2012. OWNERS MAY CONTACT DTNA AT 1-800-445-1980 OR ABC BUS, INC. TOLL FREE AT 1-877-427-7278.
12V25700006/07/2012
VAN HOOL IS RECALLING CERTAIN MODEL YEAR 2010-2012 C2045, 2011-2012 T2140, 2010-2011 T2145 AND 2011 TD925 MOTORCOACHES, EQUIPPED WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) MODULES, MANUFACTURED FROM AUGUST 2005, THROUGH SEPTEMBER 2011. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.
Model years in this history: 2011, 2010
Consequence and remedy
Consequence
THE VEHICLE MAY DEVIATE FROM THE INTENDED LINE OF TRAVEL, INCREASING THE RISK OF A CRASH.
Remedy
VAN HOOL WILL NOTIFY OWNERS VIA ITS DEALER ABC BUS INC. AND REPLACE THE CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON JULY 2, 2012. OWNERS MAY CONTACT THE WARRANTY ADMINISTRATOR FOR ABC BUS, INC. TOLL FREE AT 1-877-427-7278.
10V60300012/01/2010
VAN HOOL IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2011 TRANSIT BUSES AND MOTORCOACHES MANUFACTURED FROM AUGUST 2002 THROUGH OCTOBER 2010, EQUIPPED WITH HADLEY REMOTE MIRROR SWITCHES, PART NUMBERS 509VH AND 509VH1F. THE REAR VIEW MIRROR SWITCH MAY OVERHEAT, CAUSING THE PLASTIC HOUSING TO MELT.
Model years in this history: 2010, 2009, 2008, 2007, 2006
Consequence and remedy
Consequence
EXCESSIVE HEATING CAN CAUSE A FIRE RESULTING IN SMOKE, OPERATOR DISTRACTION, OR PERSONAL INJURY. AN OVERHEATED MIRROR SWITCH COULD CAUSE THE EXTERIOR REAR VIEW MIRRORS TO NOT OPERATE. THE MIRRORS MAY NOT ADJUST PROPERLY FROM THE INTERIOR SWITCH OR OPERATE POORLY. THEREFORE, THE DRIVER MAY NOT BE ABLE TO HAVE FULL USE OF THE REAR VIEW MIRROR, INCREASING THE RISK OF A CRASH.
Remedy
VAN HOOL WILL NOTIFY OWNERS VIA ITS DEALER ABC BUS INC. OWNERS WILL HAVE THE CHOICE TO PERFORM THE REPAIR THEMSELVES OR TO TAKE THE VEHICLE(S) TO AN ABC-LOCATION FOR REPAIR, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 10, 2011. OWNERS MAY CONTACT THE WARRANTY ADMINISTRATOR FOR ABC BUS, INC. TOLL FREE AT 1-877-427-7278.
08V58100011/05/2008
VAN HOOL IS RECALLING 76 MY 2008-2009 C2045 AND T2145 MOTOR COACHES EQUIPPED WITH CATERPILLAR C13 DIESEL ENGINES. THE EXTENSION PIPES ATTACHED TO THE AFTERTREATMENT REGENERATION DEVICE (ARD) MAY DEVELOP A HOLE, AND HEAT AND FLAME MAY ESCAPE DURING A REGENERATION OF THE DIESEL PARTICULATE FILTER.
Model years in this history: 2009, 2008
Consequence and remedy
Consequence
THIS MAY RESULT IN A FIRE HAZARD.
Remedy
VAN HOOL IS WORKING WITH CATERPILLAR TO REPAIR THESE VEHICLES (PLEASE SEE 08E054). OWNERS MAY CONTACT CATERPILLAR AT 1-800-447-4986 OR VAN HOOL AT 1-407-656-7977.
08V23700005/28/2008
VAN HOOL IS RECALLING 149 MY 2004-2007 C2045, T2140, AND T2145 MOTOR COACHES EQUIPPED WITH DOGA WINDSHIELD WIPER SYSTEMS. LINKAGES WERE POORLY FINISHED. THIS COULD LEAD TO A MISALIGNMENT OF THE WINDSHIELD WIPER SYSTEM, BLOCKING THE MOTOR.
Model years in this history: 2007, 2006, 2005, 2004
Consequence and remedy
Consequence
FAILURE OF THE WIPER LINKAGES WILL LEAD TO WIPER SYSTEM BREAKDOWN. THE OPERATOR WILL HAVE REDUCED VISIBILITY WHICH COULD RESULT IN A CRASH.
Remedy
VAN HOOL IS WORKING WITH DOGA AND DOGA WILL REPLACE THE WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JULY 23, 2008. OWNERS MAY CONTACT VAN HOOL (ABC COMPANIES) AT 1-407-656-7977.
07V18600004/27/2007
ON CERTAIN MOTOR COACHES EQUIPPED WITH ZF/ARENS AS TRONIC SHIFT SELECTORS, A CELL PHONE PLACED IN THE PROXIMITY OF THE SHIFTER TOUCH PAD COULD CAUSE THE DISPLAY TO CHANGE FROM "R" (REVERSE) TO "D" (DRIVE) SHOULD THE PHONE RECEIVE A CALL.
Model years in this history: 2007, 2006, 2005, 2004
Consequence and remedy
Consequence
THIS INTERFERENCE CAN CAUSE IMPROPER SHIFTING OF THE TRANSMISSION, AS FORWARD GEAR CAN BE ENGAGED FROM NEUTRAL ONLY, IF THE VEHICLE HAS BEEN STOPPED, AND IF THE BRAKE PEDAL HAS BEEN DEPRESSED. IF THE MALFUNCTION OCCURS WHILE 'R' (REVERSE) IS BEING SELECTED, THE SHIFTER MAY POSSIBLY CHANGE TO 'D' (DRIVE), INCREASING THE RISK OF A CRASH.
Remedy
VAN HOOL IS WORKING WITH ZF/ARENS TO DEVELOP A MORE EFFECTIVE REMEDY FOR THIS CAMPAIGN. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT VAN HOOL AT 1-800-222-2871 OR ZF AT 1-734-416-6200.
06V12800004/24/2006
ON CERTAIN MOTOR COACHES EQUIPPED WITH DETROIT DIESEL SERIES 60 ENGINES, THE TURBOCHARGER COMPRESSORS INSTALLED IN THESE MOTOR COACHES CAN FAIL.
Model years in this history: 2006, 2005, 2004, 2002, 2001, 2000
Consequence and remedy
Consequence
A FIRE CAN RESULT SHOULD THE TURBOCHARGER FAIL.
Remedy
DETROIT DIESEL IS CONDUCTING THIS RECALL (PLEASE SEE 06E019000) AND WILL REMEDY THESE MOTOR COACHES. THE ENGINES WILL BE REPAIRED FREE OF CHARGE. OWNERS MAY CONTACT DETROIT DIESEL AT 313-592-3708 OR VAN HOOL AT 1-407-656-7977.
04V42400008/30/2004
ON CERTAIN MOTOR COACHES, THE HOSE FITTINGS OF THE POWER STEERING PRESSURE FEED LINES MAY HAVE BEEN IMPROPERLY CRIMPED.
Model years in this history: 2004
Consequence and remedy
Consequence
IF THE HOSE SEPARATES FROM THE FITTING, FAILURE OF THE LINES AND THE LOSS OF PRESSURE WILL RESULT IN AN INCREASED STEERING FORCE NECESSARY FOR MANEUVERING THE VEHICLE AND A CRASH MAY OCCUR.
Remedy
DEALERS WILL INSPECT AND DETERMINE THE CONDITION OF THE CRIMP FITTINGS. IF IMPROPERLY CRIMPED, STEERING LINE REPLACEMENT WILL BE REQUIRED. THE RECALL BEGAN ON JANUARY 21, 2005. OWNERS SHOULD CONTACT VAN HOOL AT 1-800-222-2871.
02V07100102/26/2002
ON CERTAIN TRANSIT BUSES EQUIPPED WITH VANNER 60 SERIES BATTERY EQUALIZERS, THE EQUALIZER COULD FAIL TO OPERATE PROPERLY AND CAUSE MALFUNCTION OF THE BATTERY CHARGING SYSTEM.
Model years in this history: 2002, 2001, 2000, 1999, 1998
Consequence and remedy
Consequence
WITHOUT FUSING, THE EQUALIZER MAY MELT, BURN, OR SMOKE, POSSIBLY RESULTING IN A FIRE OR A SMOKE FILLED BUS, THUS NECESSITATING A PASSENGER EVACUATION OF THE BUS. THE FAILURE MODE CAN CAUSE OPERATOR DISTRACTION, AND/OR POSSIBLE PERSONAL INJURY.
Remedy
VANNER IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT THE BUSES FOR CERTAIN EQUALIZERS BY THE DATE CODE. THE AFFECTED EQUALIZERS WILL BE REPLACED BY VANNER. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VANNER AT 1-800-227-6937 OR VAN HOOL/ABC COACH AT 407-656-7977.
