21V30600004/30/2021
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2017-2021 Bus and Phaeton vehicles. The sealing washer may not seat correctly in the pilot bore, allowing the high pressure fuel rail assembly to leak.
Model years in this history: 2021, 2020, 2019, 2018, 2017
Consequence and remedy
Consequence
A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy
Tiffin will work with Cummins to inspect the rail threads , and replace the rail and fuel lines if damage is found, free of charge. Owner notification letters were mailed August 11, 2021. Owners may contact Tiffin customer service at 1-256-356-8661.
20V53400009/02/2020
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2020 Bus and Phaeton motorhomes. The steering pinch bolts may not have been properly tightened.
Model years in this history: 2020
Consequence and remedy
Consequence
A loose steering pinch bolt can result in a loss of steering control, increasing the risk of a crash.
Remedy
Tiffin will notify owners, and dealers will tighten the steering bolts to specification, free of charge. The recall began August 27, 2020. Owners may contact Tiffin customer service at 1-256-356-8661.
20V43300007/28/2020
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2019-2020 Tiffin Bus and 2018-2020 Zephyr motorhomes. The windshield wipers may not work due to the control module being improperly wired.
Model years in this history: 2020, 2019
Consequence and remedy
Consequence
The wipers may stop working during inclement weather, causing limited visibility, increasing the risk of a crash.
Remedy
Tiffin will notify owners, and dealers will inspect the control module, correcting the wiring as needed, free of charge. The recall began August 13, 2020. Owners may contact Tiffin customer service at 1-256-356-8661.
19V22800003/22/2019
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2019 Phaeton, Allegro Bus, and Zephyr motorhomes. The alternating current electrical wires may have been improperly secured in the Energy Management Module, causing increased electrical resistance.
Model years in this history: 2019, 2018
Consequence and remedy
Consequence
The additional resistance can cause the wires to overheat, increasing the risk of a fire.
Remedy
Tiffin will notify owners, and dealers will inspect the Alternating Current Relay Board and make sure the wires are properly secured, free of charge. The recall began April 15, 2019. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIFF-111.
18V34100005/25/2018
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2019 Tiffin Allegro RED, Allegro Open Road, Breeze, Bus, Phaeton, and Zephyr motorhomes. The entry door on these vehicles may have been improperly assembled, allowing the door to open while the vehicle is moving.
Model years in this history: 2019, 2018
Consequence and remedy
Consequence
If the door comes open while the motorhome is moving, there is an increased risk of injury to the motorhome occupants.
Remedy
Tiffin will notify owners, and dealers will adjust the door lock mechanism, free of charge. The recall began on June 18, 2018. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-110.
17V84100012/22/2017
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2009-2018 Allegro and Allegro RED, Bus and Phaeton vehicles, 2009-2010 Bay vehicles, 2011-2018 Breeze vehicles, and 2009-2015, and 2017-2018 Zephyr vehicles. These motorhomes are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Model years in this history: 2018, 2017, 2016, 2015, 2014, 2013, 2012, 2011, 2010, 2009
Consequence and remedy
Consequence
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy
Tiffin will notify owners, and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on February 5, 2018. Owners may contact Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Owners may also contact Tiffin customer service at 1-256-356-8661.
15V88000012/28/2015
Tiffin Motorhomes (Tiffin) is recalling certain model year 2007-2015 motorhomes manufactured May 1, 2007, to December 31, 2014, equipped with certain Coachstep Double and Triple Electric Steps. The bolt that attaches the fan gear assembly to the steps may fracture allowing the fan gear to disengage from the steps. As a result, the steps may not remain in the expected position and may become unstable.
Model years in this history: 2015, 2014, 2013, 2012, 2011, 2010, 2009, 2008
Consequence and remedy
Consequence
Unstable entry and exit steps increase the risk of injury.
Remedy
Dealers will install a retainer bracket on the double step assemblies and the Coachstep Linkage Assembly will be replaced and a retainer bracket will be installed on the trip step assemblies. The recall began on Ferbuary 10, 2016. Owners may contact Tiffin customer service at 1-256-356-8661, or Lippert customer service at 1-574-537-8900.
14V27100005/22/2014
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2009-2011 Allegro, 2010-2011 Bus and Breeze, and 2008-2011 Phaeton and Zephyr recreational vehicles, equipped with LED clearance lights made by Command Electronics, Inc. In the affected vehicles, moisture may enter the light and cause a short between two connections on the circuit board.
Model years in this history: 2011, 2010
Consequence and remedy
Consequence
A short in the circuit board increases the risk of a fire.
Remedy
Tiffin will notify owners, and dealers will install a one amp inline fuse into the front and rear circuits that will blow if there is a short in any of the clearance lights, free of charge. The recall began on July 31, 2014. Owners may contact Tiffin customer service at 1-256-356-8661.
12V07100002/24/2012
TIFFIN IS RECALLING CERTAIN MODEL YEAR 2009-2010 BUS, AS WELL AS CERTAIN 2009-2011 AND 2013 ZEPHYR RECREATIONAL VEHICLE CHASSIS EQUIPPED WITH AN ELECTRONIC CONTROL MODULE, PART NUMBER 2791-NN2E-001 OR 2791-NN2E-002. WHEN THE BRAKE IS APPLIED, THE CRUISE CONTROL MAY NOT CANCEL. ADDITIONALLY, THESE VEHICLES MAY EXHIBIT AN INADVERTENT, MODERATE INCREASE IN VEHICLE SPEED UNTIL THE VEHICLE REACHES ITS GOVERNED SPEED AFTER THE CRUISE CONTROL IS SET.
Model years in this history: 2010, 2009
Consequence and remedy
Consequence
A DRIVER MAY EXPERIENCE REDUCED CONTROL OF THE VEHICLE IF EITHER THE DRIVER ATTEMPTS TO CANCEL THE CRUISE CONTROL BY APPLYING THE BRAKE OR THE VEHICLE SPEED INCREASES AND THE DRIVER IS UNAWARE OF THE INCREASED SPEED, INCREASING THE RISK OF A CRASH.
Remedy
THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 9, 2012. OWNERS MAY CONTACT TIFFIN AT 1-256-356-8661.
11V45200008/25/2011
TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2007-2011 PHAETON, MY 2008-2010 BUS, AND MY 2010 ALLEGRO MOTORHOMES EQUIPPED WITH KONGSBERG AUTOMOTIVE ADJUSTABLE BRAKE PEDALS. THE ADJUSTABLE BRAKE PEDAL ARM MAY LOOSEN ALLOWING THE ARM TO ROTATE AROUND ITS SHAFT AND SWING IN FRONT OF THE ACCELERATOR PEDAL, REDUCING BRAKING FUNCTION.
Model years in this history: 2010, 2009, 2008
Consequence and remedy
Consequence
A LOOSE BRAKE PEDAL INCREASES THE RISK OF A CRASH.
Remedy
DAMILER TRUCKS (DTNA) IS PERFORMING RECALL REPAIRS AND NOTIFICATION TO OWNERS. THE OWNERS WERE INITIALLY NOTIFIED BY DTNA TRUCKS ON DECEMBER 22, 2009, AND A FOLLOW UP NOTICE WAS MAILED TO OWNERS ON JULY 20, 2011. OWNERS MAY CONTACT DTNA WARRANTY CLAIMS DEPARTMENT AT 1-800-547-0712 OR TIFFIN MOTORHOMES AT 1-256-356-8661 FOR MORE INFORMATION.
11V08200002/08/2011
TIFFIN MOTORHOMES IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
Model years in this history: 2011, 2010, 2009, 2008, 2007, 2006, 2005, 2004, 2003, 2002, 2001, 2000, 1999, 1998, 1997
Consequence and remedy
Consequence
THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
Remedy
TIFFIN MOTORHOMES IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE SAFETY RECALL BEGAN ON FEBRUARY 17, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101.
10V41700009/14/2010
TIFFIN IS RECALLING CERTAIN MODEL YEAR 2002-2004 36 LB BAY AND MODEL YEAR 2003-2004 40 TGP BUSES EQUIPPED WITH DIMPLEX ELECTRAFLAME, SYMPHONY, OR OPTIFLAME BRANDED ELECTRIC FIREPLACES, STOVES, AND FIREPLACE INSERTS. THE PLUG IN REMOTE CONTROL RECEIVER FOR THE FIREPLACE CAN OVERHEAT.
Model years in this history: 2004, 2003
Consequence and remedy
Consequence
AN OVERHEATED RECEIVER COULD CAUSE A FIRE.
Remedy
TIFFIN WILL NOTIFY OWNERS AND DIMPLEX WILL PROVIDE OWNERS A FREE REPLACEMENT PLUG-IN REMOTE CONTROL KIT. THE SAFETY RECALL BEGAN ON OCTOBER 4, 2010. OWNERS MAY CONTACT DIMPLEX NORTH AMERICA CUSTOMER SERVICE AT 1-888-346-7539.
05V26800006/03/2005
ON CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH VEHICLE SYSTEMS' AQUA-HOT AND HYDRO-HOT WATER HEATERS, WHICH USE WEBASTO BURNER TUBES, THE BURNER TUBES DO NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY.
Model years in this history: 2005, 2004
Consequence and remedy
Consequence
THE SURFACE TEMPERATURE OF THE EXHAUST TUBE EXITING FROM THE HEATER CAN INCREASE AND COULD POTENTIALLY IGNITE COMBUSTIBLE MATERIALS IN OR AROUND THE VEHICLE.
Remedy
TIFFIN IS WORKING WITH VEHICLE SYSTEMS TO NOTIFY OWNERS AND HAVE THE REPAIR PERFORMED ON THEIR VEHICLES. OWNERS MAY CONTACT VEHICLE SYSTEMS AT 1-800-685-4298 OR TIFFIN AT 256-356-8661.
04V38300008/03/2004
THE SEAT BELT ASSEMBLIES ON CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE LOOP LOAD REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209. "SEAT BELT ASSEMBLIES."
Model years in this history: 2005, 2004
Consequence and remedy
Consequence
THE SEAT BELT BUCKLE MAY UNLATCH IN THE EVENT OF A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY TO THE SEAT OCCUPANT.
Remedy
AMSAFE WILL REPLACE THE BUCKLES. OWNERS SHOULD CONTACT AMSAFE AT 574-266-8330 OR TIFFIN AT 1-256-356-8661.
01V09700806/22/2001
VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH SAFETY BELT ASSEMBLIES PRODUCED BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
Model years in this history: 2001, 2000
Consequence and remedy
Consequence
SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.
Remedy
AM-SAFE NOTIFIED TIFFIN'S CUSTOMERS TO RETURN THEIR VEHICLE TO AN AUTHORIZED DEALER TO HAVE THE SEAT BELTS REPAIRED FREE OF CHARGE. OWNER NOTIFICATION BEGAN AUGUST 31, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AM-SAFE COMMERCIAL PRODUCTS AT 219-266-8330.
