Model-level recall history

Tiffin ALLEGRO BUS recalls by year

Explore official NHTSA model-level records from 1998 through 2027. Choose a year to review consequences, remedies, campaign numbers, and instructions for that year and model.

79NHTSA recall records

28unique campaigns

30model years represented

Year-by-year record count

Recall history across model years

Affected systems

Frequently represented components

Component counts describe records in the NHTSA dataset, not failure rates.

Equipment: Recreational vehicle/trailer16 records across 5 unique campaigns

Equipment: Appliance: Oven/stove/cooktop9 records across 1 unique campaign

Electrical system6 records across 3 unique campaigns

Seat belts: Rear/other: Anchorage5 records across 1 unique campaign

Visibility: Windshield wiper/washer5 records across 1 unique campaign

Electrical system: Ignition4 records across 1 unique campaign

Electrical system: Wiring: Fuses and circuit breakers4 records across 2 unique campaigns

Steering: Gear box: Shaft pitman4 records across 1 unique campaign

Structure: Frame and members: Underbody shields4 records across 1 unique campaign

Trailer hitches4 records across 1 unique campaign

Equipment: Other: Labels3 records across 1 unique campaign

Service brakes, hydraulic: Pedals and linkages3 records across 1 unique campaign

Seat belts2 records across 2 unique campaigns

Service brakes, air: Antilock2 records across 1 unique campaign

Suspension2 records across 1 unique campaign

Engine and engine cooling1 records across 1 unique campaign

Equipment1 records across 1 unique campaign

Power train: Axle hubs1 records across 1 unique campaign

Seats1 records across 1 unique campaign

Unknown or other1 records across 1 unique campaign

Visibility: Rearview mirrors/devices: Exterior1 records across 1 unique campaign

Campaign history

Recently reported Tiffin ALLEGRO BUS campaigns

Campaigns are grouped across the model years represented on this page.

26V41200006/29/2026

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2026-2027 Zephyr, Wayfarer, Phaeton, Open Trail, GT1, Allegro Red, Allegro Open Road, Allegro Bus, Allegro Bay, 2026 Midas, Byway, and Allegro Breeze recreational vehicles, equipped with certain MaxxAir N-Series Maxxfan rooftop ventilation fans. The printed circuit board may fail during certain operations and overheat.

Model years in this history: 2027, 2026

Consequence and remedy

Consequence

An overheated printed circuit board increases the risk of a fire.

Remedy

Dealers will replace the circuit board, free of charge. Owner notification letters are expected to be mailed August 28, 2026. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-149. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning August 28, 2026.

24V56600007/30/2024

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022-2025 Phaeton, Allegro Bus, and Zephyr motorhomes. The PowerGlide chassis controller may have insufficient circuit protection, which can result in a blown fuse and cause an engine shutdown.

Model years in this history: 2025, 2024, 2023, 2022

Consequence and remedy

Consequence

An engine shutdown increases the risk of a crash.

Remedy

Dealers will install circuit protection, free of charge. Owner notification letters were mailed September 13, 2024. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-141.

24V03600001/23/2024

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022 Allegro Bus, Phaeton, Allegro Red 360, and Zephyr motorhomes. The pedestal mounting plate on the driver's seat may be improperly welded, which can cause the plate to separate and the seat assembly to loosen or detach.

Model years in this history: 2022

Consequence and remedy

Consequence

A loose or detached seat assembly increases the risk of injury.

Remedy

Dealers will inspect for a missing weld and replace the pedestal, as necessary, free of charge. Owner notification letters are expected to be mailed March 22, 2024. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-135.

23V64300009/20/2023

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2016-2024 Allegro Bus, and 2017-2024 Zephyr motorhomes. The 240-Volt induction cooktop may not be grounded, which can create an electrical shock hazard if the wires short-circuit.

Model years in this history: 2024, 2023, 2022, 2021, 2020, 2019, 2018, 2017, 2016

Consequence and remedy

Consequence

An electrical shock can increase the risk of injury.

Remedy

Dealers will install a ground for the metal junction box, free of charge. Owner notification letters were mailed October 20, 2023. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-133.

23V40600006/05/2023

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022-2023 Phaeton, Allegro Bus, and Zephyr motorhomes built on PowerGlide chassis. A fuse will trip during an a/c compressor failure, causing a loss of power to the chassis.

Model years in this history: 2023, 2022

Consequence and remedy

Consequence

Loss of power to the chassis can cause an engine stall, increasing the risk of a crash.

Remedy

Dealers will inspect the chassis controller, and install a harness and inline fuse as necessary, free of charge. Owner notification letters were mailed June 20, 2023. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-131.

22V58900008/05/2022

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022 Zephyr, 2022-2023 Phaeton, Allegro Breeze and Allegro Bus motorhomes equipped with a Powerglide chassis. The chassis fuse can overheat while the motorhome is in motion, possibly causing the dash display to go blank and the engine to stall.

Model years in this history: 2023, 2022

Consequence and remedy

Consequence

An engine that shuts down unexpectedly increases the risk of a crash.

Remedy

Dealers will inspect and replace the defective fuse, as necessary, free of charge. Owner notification letters were mailed August 31, 2022. Owners may contact Tiffin's customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-126.

21V68000011/05/2021

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2022 Allegro Breeze, Allegro Red, Allegro, Allegro Bus, Phaeton, and 2018-2021 Zephyr recreational vehicles. The sofa seat belts may not have been installed correctly, which could result in unsecured passengers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."

Model years in this history: 2022, 2021, 2020, 2019, 2018

Consequence and remedy

Consequence

Unsecured passengers have an increased risk of injury in the event of a crash.

Remedy

Dealers will inspect and repair the seat belts as necessary, free of charge. Owner notification letters were mailed October 29, 2021. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-118.

16V63800009/02/2016

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2017 Allegro Bus motorhomes manufactured April 12, 2016, to June 21, 2016. Due to insufficient holding power of the mirror arm swivel mechanism, the passenger side mirror could move while the vehicle is in motion.

Model years in this history: 2017

Consequence and remedy

Consequence

If the mirror does not stay in position, it can reduce the driver's visibility, increasing the risk of a crash.

Remedy

Tiffin will notify owners, and dealers will install a retrofit kit to secure the passenger mirror swivel arm mechanism, free of charge. The recall began on September 9, 2016. Owners may contact Tiffin customer service at 1-256- 356-8661. Tiffin's number for this recall is TIF-103.

16V53200007/13/2016

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2007-2011 Allegro, Allegro Bus, Phaeton, and Zephyr motorhomes, 2007-2010 Allegro Bay motorhomes, and 2010-2011 Allegro Breeze motorhomes. The windshield wiper arms on the affected vehicles may break off.

Model years in this history: 2011, 2010, 2009, 2008, 2007

Consequence and remedy

Consequence

If the windshield wiper arms break, the driver's visibility may be reduced, increasing the risk of a crash.

Remedy

Tiffin will notify owners, and dealers will replace the wiper blade arms, free of charge. The recall began on August 19, 2016. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIFF-100.

14V60900009/30/2014

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2013-2015 Allegro Bus 45 foot LP, 37 foot, and 40 foot motorhomes. In the affected vehicles, the Federal Certification label incorrectly states the front Gross Axle Weight Rating (GAWR). As such, the vehicles do not conform to Part 567, "Certification."

Model years in this history: 2015, 2014, 2013

Consequence and remedy

Consequence

If the motorhome is loaded to the incorrect specifications listed on the label, tire failure may result, increasing the risk of a crash.

Remedy

Tiffin will notify owners and send a corrected sticker for the customer to put over the incorrect sticker, free of charge. The recall began early October 2014. Owners may contact Tiffin customer service at 1-256-356-8661.

14V43000007/16/2014

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2013 Allegro Bus recreational vehicles equipped with Villa ISS GSK driver and passenger seats. The seat belt attachment may be incorrect and the seat belt may fray if it rubs along a steel bracket in the seat, reducing its strength. As such, these seats do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies."

Model years in this history: 2013

Consequence and remedy

Consequence

The weakened seat belt may fail to properly restrain the seat occupant in the event of a crash, increasing the risk of injury.

Remedy

Tiffin will notify owners, and dealers will inspect for the correct seat belt installation, or re-assemble the seat belt correctly with proper attachment hardware if necessary, free of charge. The recall began on August 25, 2014. Owners may contact Tiffin customer service at 1-256-356-8661.

14V43100007/16/2014

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2014 Allegro Bus recreational vehicles equipped with certain Villa International ABTS driver and passenger ABTS seats. The seat belt attachment may be incorrect and the seat belt may fray if it rubs along a steel bracket in the seat, reducing its strength. As such, these seats do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies."

Model years in this history: 2014

Consequence and remedy

Consequence

The weakened seat belt may fail to properly restrain the seat occupant in the event of a crash, increasing the risk of injury.

Remedy

Tiffin will notify owners, and dealers will inspect and, as necessary, repair the single link system with fasteners and re-attaching the seat belt bracket, free of charge. The recall began in August 18, 2014. Owners may contact Tiffin customer service at 1-256-356-8661.

12V52600010/31/2012

Tiffin Motorhomes is recalling certain model year 2010-2013 Allegro Bus motorcoaches, manufactured from March 2010, through September 2012 and equipped with a Cummins EPA 2010 ISL engine. Insufficient shielding between the exhaust pipe and floor may cause possible overheating of the floor above the engine compartment.

Model years in this history: 2013, 2012, 2011, 2010

Consequence and remedy

Consequence

If the exhaust pipe in the engine compartment were to fail, the escaping exhaust gases could make the floor area above the engine extremely hot, increasing the risk of personal injury or possibly resulting in a fire.

Remedy

Tiffin Motorhomes will notify owners, and dealers will install a heat shield, free of charge. The safety recall began on November 14, 2012. Owners may contact Tiffin at 1-256-356-8661.

11V48500009/23/2011

TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2011 ALLEGRO BUS AND PHAETON RECREATIONAL VEHICLES BUILT ON THE POWERGLIDE CHASSIS EQUIPPED WITH A CUMMINS ISX OR ISL DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.

Model years in this history: 2011

Consequence and remedy

Consequence

IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.

Remedy

TIFFIN MOTORHOMES IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR TIFFIN MOTORHOMES AT 1-256-356-8661.

10V51200010/25/2010

TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2011 ALLEGRO, ALLEGRO BUS, AND PHAETON RVS EQUIPPED WITH ATWOOD 35 SERIES RANGE OVENS. A POTENTIAL EXISTS FOR A SMALL FRACTURE WITHIN THE LINE DELIVERING GAS TO THE OVEN CAVITY BURNER. SUCH A FRACTURE MAY CAUSE PROPANE GAS TO LEAK FROM THE LINE.

Model years in this history: 2011

Consequence and remedy

Consequence

A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE AND/OR EXPLOSION CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY.

Remedy

TIFFIN IS WORKING WITH ATWOOD AND WILL REPLACE OR REPAIR THE STOVES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 28, 2010. OWNERS MAY CONTACT ATWOOD AT 1-574-266-4749 OR TIFFIN 1-256-356-8661.

09V49600012/29/2009

TIFFIN IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 ALLEGRO BUS MODELS WITH POWERGLIDE CHASSIS EQUIPPED WITH PNEUMATIC AND HYDRAULIC ADJUSTABLE BRAKE PEDAL ASSEMBLIES P/NOS. 6562618, 6565118, 77025-001, 77025-002, 77025-501, 77050-004, SUPPLIED BY KONGSBERG AUTOMOTIVE. SOME ASSEMBLIES COULD CONTAIN A DRIVE PIN THAT IS BELOW SPECIFICATION AND MAY BECOME DISENGAGED FROM THE BRAKE ARM CAUSING SEPARATION OR LOOSENING OF THE PEDAL FROM THE REMAINDER OF THE ASSEMBLY.

Model years in this history: 2010, 2009, 2008

Consequence and remedy

Consequence

IF THE DRIVE PIN BECOMES DISENGAGED ON THE BRAKE PEDAL ASSEMBLY, IT COULD RESULT IN A LOSS OF VEHICLE BRAKING FUNCTION AND/OR CAUSE THE BRAKE PEDAL TO INTERFERE WITH THE THROTTLE PEDAL FUNCTION. EITHER CONDITION COULD RESULT IN A VEHICLE CRASH.

Remedy

TIFFIN IS WORKING WITH KONGSBERG TO REMEDY THESE MOTORHOMES. PLEASE SEE KONGSBERG'S DEFECT REPORT 09E-064. KONGSBERG WILL SUPPLY KITS TO TIFFIN. THE REMEDY WILL BE PERFORMED BY TIFFIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 19, 2010. OWNERS MAY CONTACT TIFFIN AT 1-256-356-8661.

09V44300011/17/2009

TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLE EQUIPPED WITH NORCOLD MODEL 1200LR AND 1200LRIM REFRIGERATORS, MANUFACTURED FROM DECEMBER 1, 2001, WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.

Model years in this history: 2002, 2001

Consequence and remedy

Consequence

IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.

Remedy

TIFFIN IS WORKING WITH NORCOLD AND TIFFIN WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE BY NORCOLD. PLEASE SEE NORCOLD'S DEFECT REPORT 09E-027. OWNERS MAY CONTACT NORCOLD'S RECALL CENTER AT 1-800-767-9101.

09V12700004/16/2009

TIFFIN IS RECALLING 329 MY 2008-2009 ALLEGRO BUSES. THE REAR AXLE ABS MODULATING VALVE HAVE THE POTENTIAL TO BE WIRED INCORRECTLY. THE RIGHT AND LEFT MODULATOR VALVE HARNESS PIN COULD POSSIBLY BE REVERSED AT THE ABS ELECTRONIC CONTROL UNIT (ECU) CONNECTOR.

Model years in this history: 2009, 2008

Consequence and remedy

Consequence

UNDER SLIPPERY ROAD CONDITIONS, WHEN IN THE ABS MODE, THIS WIRING PROBLEM HAS THE POTENTIAL TO CAUSE ONE SIDE OF THE REAR WHEELS TO LOCK WHILE CAUSING LITTLE OR NO BRAKING EFFORT ON THE OPPOSITE SIDE. THIS MAY RESULT IN A LOSS OF CONTROL AND A VEHICLE CRASH.

Remedy

DEALERS WILL REMOVE THE REVERSED PINS FROM THE ECU CONNECTOR AND INSERT THEM BACK INTO THEIR CORRECT POSITION FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT TIFFIN AT 256-356-8661.

09V06900002/27/2009

TIFFIN IS RECALLING 1,408 MY 2006-2009 ALLEGRO BUS, MY 2007-2009 PHAETON AND MY 2005-2009 ZEPHYR VEHICLES BUILT ON SPARTAN CHASSIS AND EQUIPPED WITH PUTMAN HITCHES. CERTAIN TRAILER HITCHES MAY FRACTURE WHICH COULD RESULT IN THE LOSS OF THE TRAILER.

Model years in this history: 2009, 2008, 2007, 2006

Consequence and remedy

Consequence

SUSPECT HITCHES MAY DEVELOP FRACTURES AND SUBSEQUENT SEPARATION MAY OCCUR, RESULTING IN A VEHICLE CRASH, PROPERTY DAMAGE OR PEDESTRIAN HARM.

Remedy

TIFFIN IS WORKING WITH SPARTAN AND SPARTAN IS HANDLING THE REMEDY FOR THIS CAMPAIGN (PLEASE SEE 08V-567). THE TRAILER HITCH WILL BE REPLACED FREE OF CHARGE. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400 OR TIFFIN AT 256-356-8661.

09V04500002/05/2009

TIFFIN IS RECALLING 23 MY 2009 ALLEGRO BUSES EQUIPPED WITH ARVINMERITOR AXLE ASSEMBLIES. THE WHEEL END STUDS MAY HAVE BEEN IMPROPERLY TEMPERED RENDERING THEM BRITTLE AND SUSCEPTIBLE TO FRACTURE. IF ONE WHEEL STUD FRACTURES, THE REMAINING WHEEL STUDS ARE REQUIRED TO CARRY MORE LOAD. IF LEFT IN THIS CONDITION, THE REMAINING WHEEL STUDS MAY ALSO FRACTURE EVEN IF THEY ARE PROPERLY MANUFACTURED.

Model years in this history: 2009

Consequence and remedy

Consequence

FRACTURED WHEEL STUDS COULD RESULT IN A VEHICLE CRASH.

Remedy

TIFFIN IS WORKING WITH ARVINMERITOR WHO WILL REPLACE ANY AFTERMARKET REPLACEMENT STUD FREE OF CHARGE (PLEASE SEE 08E038). OWNERS MAY CONTACT ARVINMERITOR AT 1-248-435-8793 OR TIFFIN AT 256-356-8661.

08V50900010/07/2008

TIFFIN IS RECALLING 3,507 MY 2004-2007 ALLEGRO, ALLEGRO BAY AND ALLERO BUS, MY 2004-2005 PHAETON AND MY 2005-2007 ZEPHYR MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Model years in this history: 2007, 2006, 2005, 2004

Consequence and remedy

Consequence

RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Remedy

TIFFIN WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR TIFFIN AT 256-356-8661.

08V26900006/17/2008

DAIMLER TRUCKS IS RECALLING 2,506 MY 2008 XC MOTOR HOME CHASSIS AND THOMAS BUILT HDX SCHOOL AND TRANSIT BUSES EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD.

Model years in this history: 2009, 2008

Consequence and remedy

Consequence

IF THE WELD FAILS, VEHICLE STABILITY WHILE CORNERING COULD BE AFFECTED RESULTING IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A CRASH. IN ADDITION, THE TRANSVERSE BEAM COULD DROP TO THE GROUND CAUSING SPARKS THAT COULD CAUSE A FIRE HAZARD.

Remedy

DAIMLER TRUCKS IS WORKING WITH SAF-HOLLAND TO HAVE A VISUAL INSPECTION OF THE ADL TRANSVERSE BEAM PERFORMED. IF A WELD DEFECT IS IDENTIFIED, SAF-HOLLAND WILL PROVIDE A SERVICE REPLACEMENT KIT THAT CONTAINS A NEW TRANSVERSE BEAM, ALL NECESSARY INSTALLATION HARDWARE, BEAM REPLACEMENT, AND INSTRUCTIONS FREE OF CHARGE (PLEASE SEE 08E031). THE RECALL RECALL BEGAN ON SEPTEMBER 12, 2008 (THOMAS BUILT BUSES) AND OCTOBER 8, 2008. OWNERS MAY CONTACT SAF-HOLLAND AT 1-231-773-3271 OR DAIMLER TRUCKS AT 1-800-547-0712.

08V02700001/25/2008

CERTAIN MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS AND EQUIPPED WITH ZF MODEL 8018 STEERING GEARS MAY HAVE BEEN ASSEMBLED WITH THE INCORRECT RECIRCULATING BALL SPACER. THIS COULD POTENTIALLY ALLOW THE RECIRCULATING BALLS TO ESCAPE FROM THE RECIRCULATING BALL CIRCUIT RESULTING IN A LOSS OF STEERING.

Model years in this history: 2008, 2007, 2006, 2005

Consequence and remedy

Consequence

THE OPERATOR MAY NOTICE HIGHER REQUIRED STEERING WHEEL INPUTS, OR THE NEED FOR MORE STEERING WHEEL ADJUSTMENTS WHILE DRIVING IN A STRAIGHT LINE IN COMBINATION WITH METALLIC CRACKING NOISES PRIOR TO A LOSS OF STEERING. LOSS OF STEERING COULD RESULT IN A VEHICLE CRASH.

Remedy

TIFFIN IS WORKING WITH FREIGHTLINER TO REPLACE THE STEERING GEAR FREE OF CHARGE (PLEASE SEE 07V343 AND 07E049). OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712 OR TIFFIN AT 256-356-8661.

07V51700011/05/2007

ON CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION, THESE REFRIGERATORS MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Model years in this history: 2004, 2003, 2002, 2001, 2000, 1999, 1998

Consequence and remedy

Consequence

RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Remedy

TIFFIN MOTORHOMES WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR TIFFIN AT 1-256-356-8661.

Choose your exact model year

Watch the vehicle you own.

Open its year-specific page, review the current records, and start a free model-level recall watch.

2027 Tiffin ALLEGRO BUS2 records 2026 Tiffin ALLEGRO BUS2 records 2025 Tiffin ALLEGRO BUS1 records 2024 Tiffin ALLEGRO BUS2 records 2023 Tiffin ALLEGRO BUS4 records 2022 Tiffin ALLEGRO BUS6 records 2021 Tiffin ALLEGRO BUS2 records 2020 Tiffin ALLEGRO BUS2 records 2019 Tiffin ALLEGRO BUS2 records 2018 Tiffin ALLEGRO BUS2 records 2017 Tiffin ALLEGRO BUS2 records 2016 Tiffin ALLEGRO BUS1 records