23V12100002/24/2023
Thor Motor Coach (TMC) is recalling certain 2018-2021 Hurricane and Windsport recreational vehicles. The driver and front passenger overhead cabinets may detach.
Model years in this history: 2021, 2020, 2019, 2018
Consequence and remedy
Consequence
Overhead cabinets that detach while the vehicle is in motion can fall onto seat occupants, increasing the risk of a crash or injury.
Remedy
Dealers will inspect and reinstall the overhead cabinets, if necessary, free of charge. Owner notification letters were mailed March 15, 2023. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000290.
22V07600002/10/2022
Thor Motor Coach (TMC) is recalling certain 2022 ACE, Freedom Traveler, Hurricane, and Windsport motorhomes. The rear ladder may have been installed on the wrong side of the motorhome.
Model years in this history: 2022
Consequence and remedy
Consequence
An incorrectly installed ladder may break while in use, increasing the risk of injury.
Remedy
Dealers will inspect the location of the rear ladder, and reinforce or relocate the ladder as needed, free of charge. Owner notification letters were mailed March 24, 2022. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000255.
20V80400012/21/2020
Thor Motor Coach (TMC) is recalling certain 2018-2019 Hurricane and Windsport motorhomes. The overhead cabinets located above the driver and front passenger seats may detach and fall onto the seat occupants, possibly causing the driver to lose control of the vehicle.
Model years in this history: 2019, 2018
Consequence and remedy
Consequence
A loss of vehicle control can increase the risk of a crash.
Remedy
TMC will notify owners, and dealers will inspect the overhead cabinets, and reinstall them as necessary, free of charge. The recall began January 29, 2021. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000208.
20V49800008/21/2020
Thor Motor Coach (Thor) is recalling certain 2019-2021 Hurricane and Windsport motorhomes, models 27B, 29M, 32T, 33X, 34J, 34R and 35M. The electronic control center circuit board may be damaged from voltages over 17 volts causing damage to the circuit board.
Model years in this history: 2021, 2020, 2019
Consequence and remedy
Consequence
A damaged circuit board could increase the risk of a fire.
Remedy
Thor will notify owners, and dealers will add an additional circuit module to the existing component board to provide reverse polarity and over-current protection, free of charge. The recall began October 20, 2020. Owners may contact Thor customer service at 1-877-855-2867. Thor's number for this recall is RC000203.
20V33900006/09/2020
Thor Motor Coach (TMC) is recalling certain 2020-2021 ACE, 2021 Four Winds and 2020 Gemini, Axis, Compass, Delano, Windsport, Hurricane, Outlaw, and Vegas motorhomes. The adhesive bond between the glass and the metal hinge frame of the frameless windows may fail which would then allow the glass to detach and fall out.
Model years in this history: 2020
Consequence and remedy
Consequence
If the window glass detaches while the vehicle is moving it could become a projectile, increasing the risk of a crash.
Remedy
TMC will notify owners, and dealers will inspect the frameless windows for proper adhesive bond strength, replacing the windows as necessary, free of charge. The recall began July 10, 2020. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000192.
18V70500010/09/2018
Thor Motor Coach (TMC) is recalling certain 2013 Thor Ace, Daybreak, Challenger, Windsport, Hurricane, Outlaw, Tuscany, and Palazzo motorhomes. The windshield wiper system may have been incorrectly installed, causing the wipers to fail during use, reducing driver visibility.
Model years in this history: 2013
Consequence and remedy
Consequence
A reduction of driver visibility can increase the risk of a crash.
Remedy
TMC will notify owners, and dealers will verify that the windshield wiper system is installed correctly, repairing or replacing the wiper system as needed, free of charge. The recall began November 28, 2018. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000161.
17V75800011/22/2017
Thor Motor Coach (Thor) is recalling various 2003-2018 recreational vehicles, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. See a list of the affected trailer models at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V758-5764.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Model years in this history: 2018, 2017, 2016, 2015, 2014, 2013, 2012, 2011, 2010, 2009, 2008, 2007, 2006, 2005, 2004, 2003
Consequence and remedy
Consequence
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy
Thor will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Thor customer service at 1-877-500-1020, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.
17V69200011/02/2017
Thor Motor Coach (TMC) is recalling certain 2018 Ace, Axis, Hurricane, Windsport, and Vegas motorhomes. The wiring for the trailer lights may have been inserted into the wrong locations of the trailer lighting socket causing the trailer lights to not function properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Model years in this history: 2018
Consequence and remedy
Consequence
If the trailer lights do not function as intended, it can increase the risk of a crash.
Remedy
Thor has notified owners and dealers will re-wire a new connector, free of charge. The recall began on November 21, 2017. Owners may contact TMC customer service at 1-877-500-1020. TMC's number for this recall is RC000148.
17V63400010/09/2017
Thor Motor Coach (TMC) is recalling certain 2017-2018 Challenger, Axis, Chateau, Four Winds, Hurricane, Miramar, Palazzo, Tuscany, Vegas, Venetian, and Windsport motorhomes. The cargo carrying capacity (CCC) label on these vehicles may indicate an incorrect water capacity for the water heater/fresh water tank. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 120, "Tires and Rims for Motor vehicles over 10,000lbs."
Model years in this history: 2018, 2017
Consequence and remedy
Consequence
If the water capacity information is incorrect and it causes the vehicle to be over loaded, there would be an increased risk of a crash.
Remedy
TMC will notify owners and send them corrected labels, free of charge. The recall began on November 15, 2017. Owners may contact TMC customer service at 1-877-500-1020. TMC's number for this recall is RC000147.
17V55500009/07/2017
Thor Motor Coach (TMC) is recalling certain 2014-2016 Ace, Challenger, Daybreak, Hurricane, Miramar, Outlaw, Windsport, Palazzo, Tuscany, and Tuscany XTE motorhomes. The windshield wipers may fail due to the system being incorrectly installed or secured.
Model years in this history: 2016, 2015, 2014
Consequence and remedy
Consequence
If the windshield wipers cannot be used, driver visibility would be reduced, increasing the risk of a crash.
Remedy
TMC will notify owners, and dealers will inspect the wiper system to verify it is installed correctly, repairing or replacing the system as necessary, free of charge. The recall began on September 27, 2017. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000146. Note: Although some of the vehicles included in this recall have previously been remedied under recalls 17V-096 or 17V-162, the vehicles may need additional repairs under this campaign.
17V54400008/31/2017
Thor Motor Coach (TMC) is recalling certain 2010-2011 Hurricane, and 2011 Serrano and Windsport motorhomes. The affected vehicles are wired to be powered by a generator and are equipped with an Iota ITS-50R transfer switch that may fail when exposed to elevated electrical loads and used in higher temperatures.
Model years in this history: 2011
Consequence and remedy
Consequence
The transfer switch may overheat, increasing the risk of a fire.
Remedy
TMC will notify owners, and dealers will replace the Iota ITS-50R transfer switch with a transfer switch from another manufacturer, free of charge. The recall began on September 7, 2017. Owners may contact TMC customer service at 1-877-500-1020. Thor's number for this recall is RC000145.
17V23900004/10/2017
Thor Motor Coach (TMC) is recalling certain 2017 Ace, Hurricane, and Windsport motorhomes. The weight rating labels for the tow hitches on these vehicles indicate a 10,000lb weight capacity when the actual hitch capacity is 8,000lbs.
Model years in this history: 2017
Consequence and remedy
Consequence
If the hitch is loaded to the capacity on the label, the hitch may damage the motorhome or the hitch may disconnect from the tow vehicle, increasing the risk of the crash.
Remedy
TMC will notify owners and provide them corrected labels, free of charge. The recall began on May 22, 2017. Owner's may contact TMC customer service at 1-877-500-1020.
17V16200003/13/2017
Thor Motor Coach (TMC) is recalling certain 2014-2015 ACE, Hurricane, Challenger, Daybreak, Miramar, Outlaw, and Windsport motorhomes. These vehicles have windshield wiper systems that may have been improperly installed and secured, possibly causing the wipers to fail during use.
Model years in this history: 2016, 2015, 2014
Consequence and remedy
Consequence
Failure of the windshield wipers may impair the driver's visibility, increasing the risk of a crash.
Remedy
TMC has notified owners, and dealers will inspect and tighten the wiper arm securing nuts, free of charge. The recall began on May 5, 2017. Owners may contact TMC customer service at 1-877-855-2867.
16V13900003/07/2016
Thor Motor Coach (TMC) is recalling certain model year 2014-2016 Hurricane and Windsport motor homes manufactured January 30, 2013, to March 6, 2015. In the affected motor homes, the vehicle exhaust is located near a storage compartment where heat may build-up, causing the compartment to melt.
Model years in this history: 2016, 2015, 2014
Consequence and remedy
Consequence
Heat build-up in the vehicle storage compartment increases the risk of fire.
Remedy
TMC will notify owners, and dealers will install a heat shield to prevent heat build-up in the storage compartment. The recall began on April 20, 2016. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000112.
15V74500011/10/2015
Thor Motor Coach (Thor) is recalling certain model year 2011-2016 Thor Challenger, Thor Citation, Thor Hurricane, Thor Tuscany, Thor Windsport, 2011-2012 Thor Astoria, Thor Avanti, Thor Chateau, 2011-2014 Thor Daybreak, 2011-2015 Thor Outlaw, Thor Siesta, 2014-2015 Thor Miramar, 2012 Thor Four Winds, 2008-2011 Damon Astoria, Damon Daybreak, Damon Outlaw, Damon Tuscany, 2008-2012, Damon Challenger, 2008-2010 Damon Essence, 2009-2011 Damon Avanti, Four Winds Chateau, Four Winds Citation, Four Winds Four Winds, Four Winds Hurricane, Four Winds Siesta, Four Winds Windsport, 2009-2010 Four Winds Dorado, Four Winds Dutchmen, Four Winds Magellan, Four Winds Mandalay and 2009 Four Winds Fun Mover, and Four Winds Presidio motorhomes. The affected vehicles are equipped with certain Lippert-brand Coachstep Double and Triple Electric Steps. These steps use a bolt to attach the fan gear assembly to the steps. This bolt may fracture allowing the fan gear to disengage from the steps. As a result, the steps may not remain in the expected position and may be unstable.
Model years in this history: 2016, 2015, 2014, 2013, 2012, 2011
Consequence and remedy
Consequence
Unstable entry and exit steps increase the risk of injury.
Remedy
Thor will notify owners, and dealers will install a retainer bracket to reinforce the operating mechanism and replace all of the affected bolts, free of charge. The recall began on January 6, 2016. Owners may contact Thor customer service at 1-877-855-2867. Thor's number for this recall is RC000111.
15V71900010/30/2015
Thor Motor Coach (TMC) is recalling certain model year 2016 Ace, Challenger, Hurricane, Miramar, Outlaw, and Windsport vehicles manufactured July 14, 2015, to October 16, 2015. Due to an incorrect shift cable bracket and an improper shift cable adjustment, the affected vehicles can be shifted out of 'PARK' without applying the brakes.
Model years in this history: 2016
Consequence and remedy
Consequence
If the vehicle can be shifted into reverse without the brakes being applied, the vehicle may unintentionally move, increasing the risk of a crash.
Remedy
Ford will notify owners on TMC's behalf, and Ford dealers will replace the transmission shift control bracket and adjust the transmission shift cable, free of charge. The recall began on November 12, 2015. Owners may contact TMC customer service at 1-877-500-1020. TMC's number for this recall is RC000110.
15V69900010/23/2015
Thor Motor Coach (TMC) is recalling certain model year 2016 Challenger, Hurricane and Windsport motorhomes manufactured July 31, 2015, to September 9, 2015. In the affected vehicles, the parking brake actuator may be out of calibration causing the parking brake system to not properly hold the vehicle even with the parking brake pedal fully depressed. Additionally, the parking brake may not disengage completely when the parking brake pedal is released.
Model years in this history: 2016
Consequence and remedy
Consequence
If the parking brake does not fully engage, the vehicle may unexpectedly roll, increasing the risk of personal injury or a crash. A parking brake that drags may result in a wheel end fire.
Remedy
TMC will notify owners, and dealers will replace the parking brake foot pedal assembly, free of charge. The recall began on November 16, 2015. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000107.
15V26500005/07/2015
Thor Motor Coach (TMC) is recalling certain model year 2016 Hurricane and Windsport motorhomes manufactured March 10, 2015, to March 24, 2015. In the affected motorhomes, the co-pilot seats may be attached to the floor of the motorhome in an area that is not properly reinforced.
Model years in this history: 2016
Consequence and remedy
Consequence
If the floor at the attachment point is not properly reinforced, the seat base mounting may loosen over time, increasing the risk of injury in the event of a crash.
Remedy
TMC will notify owners, and dealers will install a reinforcement plate at the co-pilot seat mounting bolt location, free of charge. The recall began on June 22, 2015. Owners may contact TMC customer service at 1-877-500-1020. TMC's number for this recall is RC000101.
15V00400001/08/2015
Thor Motor Coach (TMC) is recalling certain model year 2015 Challenger, Four Winds 5000, Hurricane, Miramar, Chateau Citation, Chateau, Windsport, and Palazzo motorhomes manufactured April 24, 2014, to December 11, 2014, and equipped with certain Latitude awnings manufactured by Carefree of Colorado. The affected awnings may have screws that attach the lateral arm brackets to the mounting brackets that were not manufactured to specification.
Model years in this history: 2015
Consequence and remedy
Consequence
The screws could fail, causing the supporting bracket to fail, and the awning to fall and potentially strike and injure a person beneath it.
Remedy
TMC will notify owners, and dealers will remove and replace the defective screws, free of charge. The recall began January 23, 2015. Owners may contact TMC customer service at 1-877-500-1020. TMC's number for this recall is RC000097.
14V69500011/03/2014
Thor Motor Coach (Thor) is recalling certain model year 2015 Four Winds 5000, Hurricane, Miramar, Chateau Citation, Chateau, Four Winds Siesta, Windsport, and Freedom Elite motorhomes manufactured August 7, 2014, to October 17, 2014. The affected motorhomes have awnings whose mounting brackets may crack, and the awnings may fall.
Model years in this history: 2015
Consequence and remedy
Consequence
If an awning falls, there is an increased risk of injury to anyone under the awning.
Remedy
Thor has notified owners, and dealers will replace the defective mounting brackets, free of charge. The recall began on November 10, 2014. Owners may contact Thor customer service at 1-877-855-2867. Thor's number for this recall is RC000095.
13V26500006/25/2013
Thor Motor Coach (Thor) is recalling certain model year 2006-2013 Windsport, model year 2006-2010 Magellan, model year 2007-2013 Hurricane, model year 2009-2013 Serrano and model year 2011-2013 A.C.E motorhomes. The motorhomes are equipped with an RV Custom Products Battery Control Center (BCC) which may experience a failure while the motorhome is in motion.
Model years in this history: 2013, 2012, 2011, 2010, 2009, 2008, 2007, 2006
Consequence and remedy
Consequence
If the BCC fails, all power may be lost to the motorhome chassis, including all lighting, making the vehicle very difficult to operate, increasing the risk of a crash.
Remedy
Thor will notify owners, and dealers will rewire the BCC free of charge. The recall began on July 30, 2013. Customers may contact Thor at 1-877-855-2867. Thor's recall campaign number is RC000077.
13V16400004/25/2013
Thor Motor Coach is recalling certain model year 2013-2014 Challenger, Four Winds 5000, Hurricane, Chateau, Chateau Sport, and Windsport; model year 2013 Palazzo and Four Winds Siesta and model year 2014 Majestic motorhomes manufactured February 13, 2013, through April 09, 2013. If the awning installation sequence was not completely followed, the awning motor may unknowningly become damaged. A damaged motor may lead to an unfurling of the awning.
Model years in this history: 2014, 2013
Consequence and remedy
Consequence
If motor damage occurs, it is possible that the awning can unfurl unexpectedly, either while the motorhome is at rest or while in transit, increasing the risk of personal injury or a vehicle crash.
Remedy
Thor Motor Coach will notify owners and Dometic staff will replace the affected motors with a design that is not subject to an out-of-sequence installation error. The recall began during May 2013. Owners may contact Thor at 1-877-855-2867 or Dometic at 1-888-447-0003 for more information. Owners are being instructed not to drive their vehicle until repairs can be performed.
11V45900008/31/2011
THOR MOTOR COACH (TMC) IS RECALLING CERTAIN MODEL YEAR 2011-2012 WINDSPORT AND HURRICANE MOTOR HOMES MANUFACTURED FROM SEPTEMBER 3, 2010, THROUGH AUGUST 18, 2011. ON THESE VEHICLES, THE EXHAUST SYSTEM IS CLOSE TO A VEHICLE STORAGE COMPARTMENT. HEAT CAN BUILD UP IN THIS AREA.
Model years in this history: 2012, 2011
Consequence and remedy
Consequence
HEAT BUILD UP COULD RESULT IN A FIRE, PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.
Remedy
TMC WILL NOTIFY OWNERS, AND DEALERS WILL INSTALL A HEAT SHIELD TO PROTECT THE STORAGE COMPARTMENT FROM THE HEAT GENERATED BY THE EXHAUST. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 3, 2011. OWNERS MAY CONTACT TMC AT 1-877-855-2867.
