26V14700003/13/2026
Corp. Micro Bird, Inc. (Micro Bird) is recalling certain 2002-2015 MB II, 2008-2026 G5, and 2015-2026 T-Series transit buses. An installation error may prevent the wheelchair tie-downs from locking, leaving the wheelchair improperly secured.
Model years in this history: 2015, 2014, 2013, 2012, 2011, 2010, 2009, 2008, 2007, 2006, 2005, 2004, 2003, 2002
Consequence and remedy
Consequence
An unsecured wheelchair can move during transit or a crash, increasing the risk of injury.
Remedy
Dealers will inspect and secure the anchor screw cap as necessary, free of charge. Owner notification letters were mailed April 29, 2026. Owners can contact Micro Bird Customer Service at 819-477-2012. Micro Bird's number for this recall is 26-120-AUC.
24V48500006/27/2024
Corp. Micro Bird, Inc. (Micro Bird) is recalling certain 2008-2024 G5, 2008-2015 MBII, and 2015-2023 T-Series transit buses. The rear emergency door exterior handle may unexpectedly break under applied force.
Model years in this history: 2015, 2014, 2013, 2012, 2011, 2010, 2009, 2008
Consequence and remedy
Consequence
In the event of an emergency, a broken door handle can prevent or delay emergency responders from entering the vehicle, increasing the risk of injury.
Remedy
Dealers will replace the rear emergency door exterior handle, free of charge. Owner notification letters were mailed August 15, 2024. Owners may contact Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 24-109-EUC.
22V71400009/23/2022
Corp. Micro Bird, Inc. (Micro Bird) is recalling certain 2013-2022 G5, 2015-2019 T-Series, and 2012-2015 MBII transit buses. The power cable that provides electricity to the air conditioning control board may have a loose connection to the power stud on the board.
Model years in this history: 2015, 2014, 2013, 2012
Consequence and remedy
Consequence
A loose power cable connection may cause the control board to overheat and melt, increasing the risk of a fire.
Remedy
Dealers will redirect the power cable and secure the power cable connect as necessary, free of charge. Owner notification letters were mailed on March 2, 2023. Owners may contact Micro Bird's customer service at 1-819-477-2012. Micro Bird's number for this recall is 22-096-VUC.
22V28700004/28/2022
Corp. Micro Bird, Inc. (Micro Bird) is recalling certain 2006-2021 MBII and G5 transit buses. An inactive electrical harness that is secured in an opening in the B-pillar may become damaged from sharp edges inside the opening.
Model years in this history: 2019, 2018, 2017, 2016, 2015, 2014, 2013, 2012, 2011, 2010, 2009, 2008, 2007, 2006
Consequence and remedy
Consequence
A damaged electrical harness may short circuit, increasing the risk of a fire.
Remedy
Dealers will secure the electrical harness and remove the fuse linked to the main cable, free of charge. Owner notification letters were mailed on June 20, 2022. Owners may contact Micro Bird's customer service at 1-819-477-2012. Micro Bird's number for this recall is 22-092-HUS.
21V53100007/13/2021
Corp. Micro Bird, Inc. (Micro Bird) is recalling certain 2003-2015 MBII, 2015-2021 T-Series, and 2006-2022 G5 transit buses. The emergency release handle on the service door may bind, not allowing the door panels to open.
Model years in this history: 2015, 2014, 2013, 2012, 2011, 2010, 2009, 2008, 2007, 2006, 2005, 2004, 2003
Consequence and remedy
Consequence
The service door may not open, preventing evacuation of the vehicle in case of emergency, increasing the risk of injury.
Remedy
Dealers will provide instructions on how to correctly adjust the service door, free of charge. Owner notification letters were mailed on September 9, 2021. Owners may contact Micro Bird's customer service at 1-819-477-2012. Micro Bird's number for this recall is 21-087-DUC.
20V61000010/02/2020
Corp. Micro Bird Inc. (Micro Bird) is recalling certain 2019 MBII propane-powered buses. Following the relocation of the propane conversion controller grounding wire, after deactivation of the main battery cut-off switch, the propane module may fail, preventing the engine from starting or causing a short-circuit.
Model years in this history: 2019
Consequence and remedy
Consequence
A short circuit can increase the risk of a fire.
Remedy
Micro Bird will notify owners and dealers will relocate the ground, free of charge. The recall began December 1, 2020. Owners may contact Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 20-085-PUS.
20V13300003/06/2020
Corp. Micro Bird Inc. (Micro Bird) is recalling certain 2004-2021 T-Series, G5, and MBII school buses. The emergency door retaining device may fail to keep the door in an open position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 217, "Bus Emergency Exits and Window Retention and Release."
Model years in this history: 2019, 2018, 2017, 2016, 2015, 2014, 2013, 2012, 2011, 2010, 2009, 2008, 2007, 2006
Consequence and remedy
Consequence
If the emergency door won't stay open during an evacuation it can increase the risk of injury.
Remedy
Micro Bird will notify owners, and dealers will install a kit to repair the emergency door retaining device, free of charge. The recall April 24, 2020. Owners may contact Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 20-084-RUS.
19V52000007/11/2019
Corp. Micro Bird Inc. (Micro Bird) is recalling certain 2019 MBII propane-powered vehicles equipped with a main battery cut-off switch. If the main battery cut-off switch is activated, the propane conversion controller grounding wire may melt.
Model years in this history: 2019
Consequence and remedy
Consequence
A melted grounding wire may result in a short-circuit, increasing the risk of a fire in the engine compartment.
Remedy
Micro Bird will notify owners and dealers will relocate the grounding, free of charge. The recall began August 6, 2019. Owners may contact Micro Bird customer service at 1-819-477-2012, extension 364.
18V51700008/06/2018
Corp. Micro Bird Inc. (Micro Bird) is recalling certain 2015-2018 Micro Bird G5, MB II, and T-Series transit buses. During manufacturing, the seat belt anchorage plate may not have been correctly attached to the wall, limiting the capacity of the shoulder belt to restrain a passenger in the event of a crash.
Model years in this history: 2018, 2017, 2016, 2015
Consequence and remedy
Consequence
If the belt anchorage plate detaches from the wall, and cannot properly restrain a passenger it can increase the risk of injury.
Remedy
Micro Bird Corporation will provide inspection and field modification instructions and the material kit required to complete this recall repair, free of charge. Owner letters were mailed September 26, 2018. Owners may contact Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 18-075-CUC.
16V43400006/14/2016
Corp. Micro Bird Inc. (Micro Bird) is recalling certain model year 2015-2016 MBII, G5, and CT-Series commercial buses manufactured August 21, 2015, to June 2, 2016. The affected buses have T-Slider window frames that may allow water to accumulate inside the frame. In freezing conditions, the accumulated water can freeze, expand and put extra pressure on the window glass causing it to shatter.
Model years in this history: 2016, 2015
Consequence and remedy
Consequence
Shattered window glass may increase the risk of injury to the bus occupants.
Remedy
Micro Bird will notify owners, and dealers will seal or replace the windows, as necessary, free of charge. The recall began on July 19, 2016. Owners may contact Lippert Window customer service at 1-450-378-6722 or Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 16-066-LUC.
15V88400012/29/2015
Corp. Micro Bird Inc. (Micro Bird) is recalling certain model year 2014-2016 MBII and G5 transit buses manufactured September 5, 2014, to November 24, 2015. The affected vehicles may have a camber caster kit bolt that was insufficiently torqued, causing the bolt to come loose.
Model years in this history: 2016, 2015, 2014
Consequence and remedy
Consequence
An insufficiently torqued bolt may become loose and fall out causing vehicle misalignment. Loss of vehicle control is possible, increasing the risk of a crash.
Remedy
Micro Bird will notify owners, and dealers correct the torque, free of charge. The recall began on January 18, 2016. Owners may contact Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 15-065-AUC.
15V77000011/19/2015
Corp. Micro Bird Inc. (Micro Bird) is recalling certain model year 2006-2014 MB II, G5, and CT-Series transit buses manufactured January 1, 2006, to December 31, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts built by the Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Model years in this history: 2014, 2013, 2012, 2011, 2010, 2009, 2008, 2007, 2006
Consequence and remedy
Consequence
If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Remedy
Micro Bird will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on December 13, 2015. Owners may contact Micro Bird customer service at 1-819-477-2012, or Ricon Customer Service at 1-800-322-2884. Micro Bird's number for this recall is 15-063-RUC.
14V62200010/06/2014
Corp. Micro Bird Inc. (Micro Bird) is recalling certain model year 2006-2014 MB II and G5 transit buses manufactured January 1, 2006, to January 9, 2014, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.
Model years in this history: 2014, 2013, 2012, 2011, 2010, 2009, 2008, 2007, 2006
Consequence and remedy
Consequence
If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Remedy
Micro Bird will notify owners and Ricon will supply supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on December 1, 2014. Owners may contact Micro Bird customer service at 1-819-477-2012 extension 401 or Ricon customer service at 1-800-322-2884. Micro Bird's number for this recall is 14-058-RIU.
