25V85300012/10/2025
Motor Coach Industries (MCI) is recalling certain 102DL3, 102D3, MC12PTV, E4500, D4000, 102D3ISTV, D4500, J4500, D4000ISTV, D4005, D4505, and J3500 transit buses. Please refer to MCI's recall report for specific model year information. The front door lower curb view glazing material is incorrect. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 205, "Glazing Materials."
Model years in this history: 2001, 2000, 1999, 1998, 1997, 1996, 1995, 1994, 1993, 1992, 1991, 1990, 1989, 1988
Consequence and remedy
Consequence
The incorrect window glazing material may reduce the driver's visibility, increasing the risk of a crash.
Remedy
MCI will replace the glass, free of charge. Owner notification letters were mailed February 4, 2026. Owners may contact MCI customer service at 1-800-241-2947. MCI's number for this recall is 22-005.
13V49800010/17/2013
Motor Coach Industries (MCI) is recalling certain model year 2000-2012 D, E, G and J series coaches manufactured January 2000 through June 2011 and equipped with Sure Power battery equalizers containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.
Model years in this history: 2001, 2000
Consequence and remedy
Consequence
Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.
Remedy
MCI will notify owners, and Sure Power will replace the equalizers, free of charge. Owners may contact MCI at 1-847-285-2000. This campaign is MCI service bulletin 401.
06V48100012/19/2006
ON CERTAIN MOTOR COACHES, THE BOOST CONNECTOR HOUSING CAN FAIL OVER TIME, EXPOSING THE POSITIVE AND NEGATIVE TERMINALS.
Model years in this history: 2006, 2005, 2004, 2003, 2002, 2001, 2000, 1999, 1998, 1997
Consequence and remedy
Consequence
THIS COULD RESULT IN THE GROUNDING OF AN UNPROTECTED CIRCUIT AND COULD LEAD TO A THERMAL EVENT IF NOT CORRECTED.
Remedy
CUSTOMERS ARE BEING ADVISED TO REMOVE THE BOOST CONNECTOR AND DISCARD IT. CUSTOMERS WILL BE OFFERED A NEW DESIGN BOOST CONNECTOR AS AN ALTERNATIVE AT NO COST. THE RECALL BEGAN ON JANUARY 2, 2007. OWNERS MAY CONTACT MCI AT 1-800-241-2947.
01V14000812/19/2001
MOTORHOMES EQUIPPED WITH DRAG LINK ASSEMBLIES CONTAINING 20-EDL MODEL BALL SOCKETS AND MANUFACTURED BY TRW. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW-SPECIFICATION CASE DEPTH AND/OR HARDNESS, WHICH CAN LEAD TO PREMATURE WEAR OF THE SOCKET.
Model years in this history: 2000, 1999
Consequence and remedy
Consequence
IF THIS CONDITION OCCURS, THE DRIVER CAN LOSE PARTIAL CONTROL OF THE RIGHT FRONT WHEEL, POSSIBLY RESULTING IN A CRASH.
Remedy
DEALERS WILL REPLACE THE DEFECTIVE DRAG LINKS. OWNER/DISTRIBUTOR NOTIFICATION BEGAN APRIL 18, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MCI AT 1-800-241-2941 OR TRW CUSTOMER SERVICE AT 1-866-280-3287.
00V23201009/06/2000
VEHICLE DESCRIPTION: MOTOR HOME CHASSIS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.
Model years in this history: 2000, 1999, 1998
Consequence and remedy
Consequence
THIS CONDITION COULD CAUSE THE ABS ECU TO EXHAUST THE AIR AT THE AIR BRAKE MODULATORS FOR ONE OR MORE OF THE WHEELS. THIS COULD RESULT IN EXTENDED BRAKING DISTANCES AND A POSSIBLE CRASH.
Remedy
DEALERS WILL REPLACE THE ABS ECU.
98V09800005/07/1998
VEHICLE DESCRIPTION: TRANSIT COACHES EQUIPPED WITH WHEEL CHAIR LIFTS. AN INSTRUCTION LABEL IDENTIFYING THE LOCATION OF THE EMERGENCY EXIT WAS OMITTED FROM THE WHEEL CHAIR SEATING POSITION LOCATED ON THE CURB SIDE OF THE VEHICLE. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 217, "BUS WINDOW RETENTION AND RELEASE."
Model years in this history: 1998
Consequence and remedy
Consequence
IN THE EVENT OF A VEHICLE CRASH OR OTHER EMERGENCY, PASSENGERS LOCATED IN THIS SEATING POSITION WILL NOT HAVE THE INFORMATION TO FIND PROPER ACCESS TO THE EMERGENCY EXIT.
Remedy
OWNERS WILL BE PROVIDED WITH A LABEL AND INSTALLATION INSTRUCTIONS.
97V05300004/03/1997
VEHICLE DESCRIPTION: BUSES EQUIPPED WITH 4-STROKE CYCLE ENGINES. ENGINE COMPARTMENT FIRES HAVE OCCURRED AT OR NEAR THE WEBASTO DIESEL FUELED AUXILIARY HEATER.
Model years in this history: 1997, 1996, 1995, 1994
Consequence and remedy
Consequence
PERSONAL INJURY AND PROPERTY DAMAGE CAN OCCUR DUE TO AN ENGINE COMPARTMENT FIRE.
Remedy
MCI IS ASKING COACH OPERATORS TO DISABLE THE WEBASTO HEATER BY DISCONNECTING THE APPROPRIATE FUSES.
95V12200006/19/1995
THE WEBBED BELT RETRACTORS USED TO SECURE A WHEEL CHAIR IN THE BUS FAIL WHEN THE PLASTIC RETRACTOR COVER SEPARATES ALLOWING THE COVER TO OPEN. THIS CAN ALLOW THE INTERNAL RETRACTOR SPRING TO RELEASE OUT OF THE RETRACTOR.
Model years in this history: 1995
Consequence and remedy
Consequence
THE RETRACTOR COULD FAIL TO HOLD AN OCCUPANT IN THE EVENT OF A VEHICLE ACCIDENT.
Remedy
DEALERS WILL RETROFIT THE WHEEL CHAIR SECUREMENT RETRACTORS.
94V02000002/04/1994
THE BRAKE ROD TO BRAKE ARM ATTACHING NUT AND BOLT ARE UNDERTORQUED AND MAY LOOSEN AND FALL OFF CAUSING SEPARATION OF THE ROD AND ARM.
Model years in this history: 1993, 1992, 1991
Consequence and remedy
Consequence
SEPARATION OF THE BRAKE ROD AND THE BRAKE ARM RESULTS IN THE TOTAL LOSS OF THE SERVICE BRAKES WHICH MAY RESULT IN AN ACCIDENT.
Remedy
MCI WILL SUPPLY 1/2" UNF "STOVER" LOCKNUT TO CUSTOMERS. THIS LOCKNUT SHOULD BE INSTALLED IMMEDIATELY AND TORQUED TO 40 LB/FT (54 NM). A FASTENER WILL ALSO BE PROVIDED TO THE CUSTOMER ALONG WITH THE INSTALLATION PROCEDURES.
