14V59900009/26/2014
Forest River, Inc. (Forest River) is recalling certain model year 2006-2014 Glaval Universal, Primetime, Sport, Titan, and Titan II transit and shuttle buses manufactured January 1, 2006, to September 26, 2014, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon. The platform side plate of the affected wheelchair lifts may crack.
Model years in this history: 2014, 2013, 2012, 2011, 2010, 2009, 2008, 2007, 2006
Consequence and remedy
Consequence
If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Remedy
Forest River will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on December 1, 2014. Owners may contact Glaval customer service at 1-800-445-2825 or Ricon customer service at 1-800-322-2884.
14V22600004/30/2014
Glaval Bus (Glaval) is recalling certain model year 2007-2012 Universal, Primetime, Sport, Concorde, Titan, Titan II, Entourage and Apollo transit buses manufactured January 1, 2007, through December 3, 2012, and equipped with certain Ricon S-series and K-series wheelchair lifts, with an optional armored pendant cable. The armored cable may be positioned such that it does not clear the wheelchair lift.
Model years in this history: 2012, 2011, 2010, 2009, 2008, 2007
Consequence and remedy
Consequence
If the cable does not clear the wheel chair lift it may contact the power lug and if it does not have a nonconductive cover, or it has an improperly installed non-conductive cover, then a short circuit may occur that could result in a fire.
Remedy
Glaval will notify owners, and Ricon will send owners a supplemental cover kit and instructions, free of charge. The recall is expected to begin in June 2014. Owners may contact Glaval customer service at 1-800-445-2824 or Ricon Customer Service at 1-800-322-2884 or by e-mail at recall.admin@wabtec.com.
14V00400001/08/2014
Glaval Bus is recalling certain model year 2010-2013 Universal, Entourage, Concorde II, Titan, Titan II and Legacy transit buses manufactured June 1, 2010, through June 30, 2013, and equipped with a Ford 5.4L or 6.8L engine and a Trans/Air-brand air conditioner. In the affected vehicles, depending on the routing of the alternator harness, and the orientation of the heater hose spring clamp at the front of the intake manifold, the alternator harness may be pinched between the spring clamp and the air conditioner compressor mounting bracket.
Model years in this history: 2013, 2012, 2011, 2010
Consequence and remedy
Consequence
The charging system may fail which could lead to the vehicle stalling while driving, increasing the risk of a crash. Additionally, the spring clamp could pierce both the positive and negative wires of the alternator harness creating a short circuit which could result in a fire.
Remedy
Glaval Bus will notify owners, and Trans/Air dealers will inspect the vehicles, correct the clamp installation and repair and reroute the alternator harness, as needed, free of charge. The recall began on January 22, 2014. Customers may contact Glaval at 1-574-262-2212.
13V52000010/18/2013
Glaval Bus is recalling certain model year 2009-2010 Entourage, Sport, Universal, Titan, Titan II, Apollo, Primetime, Concorde, and Concorde II transit buses manufactured August 4, 2009, through June 7, 2010 and equipped with A&M Systems-brand electric door actuators. Voltage spikes may damage electrical components and electrical circuits within the actuator, causing the circuit board to develop high resistance.
Model years in this history: 2010, 2009
Consequence and remedy
Consequence
High resistance may cause the circuit board to overheat, increasing the risk of a fire.
Remedy
Glaval Bus will notify owners and dealers will replace the circuit board, free of charge. The recall began on November 14, 2013. Owners may contact Glaval Bus at 1-574-262-2212.
13V30900007/15/2013
Glaval Bus is recalling certain model year 2010-2013 Universal, Concorde II, Entourage, Primetime, Titan II, Apollo, and Sport buses, certain model year 2011-2013 Titan II lf and Legacy buses and certain model year 2010 Synergy buses. The affected buses are equipped with a rear interior air conditioner evaporator which may come loose from its ceiling mounting over time.
Model years in this history: 2013, 2012, 2011, 2010
Consequence and remedy
Consequence
The evaporator unit may detach from the ceiling and fall increasing the risk of injury.
Remedy
Glaval will notify owners, and dealers will tighten and replace the air conditioner evaporator mounting bolts, as needed, free of charge. The recall began on July 8, 2013. Owners may contact Glaval at 1-800-445-2825 or glavalcustomerservice@forestriverinc.com.
12V58000012/10/2012
Glaval Bus is recalling certain model year 2007-2012 transit buses, models: Entourage, Sport, Universal, Titan, Titan II, Apollo, Primetime, and Concord; and manufactured January 1, 2007, through December 3, 2012. The buses are equipped with a Ricon manufactured wheelchair lift which has an optional armored pendant cable. The cable may have been installed such that it doesn't clear the wheelchair lift and without a protective cover, or a misinstalled protective cover.
Model years in this history: 2012, 2011, 2010, 2009, 2008, 2007
Consequence and remedy
Consequence
The cable may contact the power lug at the base of the wheel chair lift causing a short circuit that could result in a fire.
Remedy
Glaval Bus will notify owners and direct them to contact Ricon. Ricon will provide a supplemental cover kit and instructions, free of charge. The recall campaign began on January 23, 2013. Owners may contact Glaval Bus at 1-574-262-2212 or Ricon at 1-818-267-3000.
12V38400008/03/2012
Glaval Bus is recalling certain model year 2011-2012 transit buses equipped with Speciality Manufacturing Inc. (SMI) ProLo roof escape hatches. Increased friction between the rear plate assemblies, p/no. 009327, and the nylon rear pop-up support, p/no. 008956, may result in opening force of the ProLo roof hatches that exceeds Federal standard requirements. Thus, these hatches fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 217, "Bus Emergency Exits and Window Retention and Release."
Model years in this history: 2012, 2011
Consequence and remedy
Consequence
In the event of an emergency, passengers' exit from the bus may be hindered, possibly resulting in injury to the vehicle occupants.
Remedy
Glaval Bus will notify owners. SMI will provide service kits along with repair instructions to dealers and owners, free of charge. The safety recall began on August 17, 2012. Owners may contact Glaval Bus at 1-574-262-2212 or SMI at 1-800-951-7867.
12V32100007/09/2012
GLAVAL IS RECALLING CERTAIN BUSES EQUIPPED WITH BRAUN CENTURY-2 AND/OR VISTA-2 WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED.
Model years in this history: 2011, 2010, 2009, 2008, 2007, 2006
Consequence and remedy
Consequence
A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIRÂ’S OCCUPANT COULD FALL AND SUSTAIN INJURY.
Remedy
GLAVAL WILL NOTIFY OWNERS, AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED BRAUN DEALERS FREE OF CHARGE. OWNERS MAY CONTACT GLAVAL BUS AT 1-800-347-7440.
12V01100001/13/2012
GLAVAL IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2007 TRANSIT BUSES BUILT ON FORD, GMC, CHEVROLET, AND FREIGHTLINER CHASSIS AND EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.
Model years in this history: 2011, 2010, 2009, 2008, 2007, 2006
Consequence and remedy
Consequence
IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND A VEHICLE FIRE MAY OCCUR.
Remedy
GLAVAL WILL NOTIFY OWNERS AND PROVIDE INFORMATION ON HOW TO OBTAIN THE RETROFIT KIT FROM CARRIER ALONG WITH REPAIR INSTRUCTIONS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 14, 2012. (SEE CARRIER'S RECALL CAMPAIGN 11E-003.) OWNERS MAY CONTACT CARRIER AT 1-800-348-7440.
11V40200008/02/2011
GLAVAL BUS IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 TITAN II AND UNIVERSAL TRANSIT BUSES MANUFACTURED FROM APRIL 1, 2010, THROUGH JULY 1, 2011. ONE OF THE FIRE SUPPRESSION DISCHARGE NOZZLES WAS INCORRECTLY PLACED IN THE DRIVER'S STATION.
Model years in this history: 2011, 2010
Consequence and remedy
Consequence
IN THE EVENT OF A SYSTEM DISCHARGE, A SIGNIFICANT CLOUD OF POWDER COULD BE RELEASED INTO THE DRIVER'S COMPARTMENT POSSIBLY OBSTRUCTING THE DRIVER'S VIEW. THIS SITUATION COULD RESULT IN A VEHICLE CRASH.
Remedy
GLAVAL BUS WILL NOTIFY OWNERS AND THE BUSES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 30, 2011. OWNERS SHOULD CONTACT GETAWAY MARKETING, INC. AT 1-941-747-5486 EXT. 221 OR GLAVAL BUS AT 1-800-445-2825.
10V61800011/23/2010
GLAVAL IS RECALLING CERTAIN MODEL YEAR 2002, 2003, 2006, 2007, AND 2008 FORD E350/E450 UNIVERSAL, CHEVY/GMC 4500/5500 TITAN AND FREIGHTLINER MB-55 APOLLO TRANSIT BUSES MANUFACTURED FROM AUGUST 1999 THROUGH JULY 2007, AND EQUIPPED WITH A TRANS/AIR TA73 EVAPORATOR. THE EVAPORATOR UTILIZES A POWER RESISTOR TO REGULATE BLOWER SPEED. SHOULD A SHORT OCCUR IN THE "LOW OR MEDIUM SPEED" CIRCUIT WHILE THE BLOWER IS IN HIGH SPEED, THE SHORT WILL CAUSE THE SUPPLY VOLTAGE TO FEEDBACK THROUGH THE RESISTOR TO GROUND, NOT DRAWING ENOUGH CURRENT TO TRIP THE FUSE.
Model years in this history: 2008, 2007, 2006, 2003, 2002
Consequence and remedy
Consequence
THIS WOULD CAUSE THE RESISTOR TEMPERATURE TO RISE TO A POINT WHERE IT WILL MELT AND POSSIBLY IGNITE THE PLASTIC BLOWER HOUSING TO WHICH IT IS MOUNTED. THE OVERHEATING CAN RESULT IN A FIRE.
Remedy
GLAVAL IN COOPERATION WITH TRANS AIR WILL INSTALL A THERMAL SHUTDOWN DEVICE IN SERIES WITH THE SPEED RESISTORS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 23, 2010. OWNERS MAY CONTACT TRANS AIR WARRANTY AND SERVICE CENTER AT 1-800-673-2446.
10V14300004/12/2010
GLAVAL BUS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 UNIVERSAL, TITAN, TITAN II, PRIMETIME, SPORT, AND APOLLO TRANSIT BUSES MANUFACTURED BETWEEN DECEMBER 2007 AND DECEMBER 2009 FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.
Model years in this history: 2010, 2009, 2008, 2007, 2006
Consequence and remedy
Consequence
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.
Remedy
GLAVAL BUS IS WORKING WITH RICON AND RICON WILL BE PERFORMING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON APRIL 26, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR GLAVAL BUS AT 1-800-322-2884.
10V14400004/12/2010
GLAVAL BUS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2010 TRANSIT BUSES MANUFACTURED BETWEEN OCTOBER 2007 THROUGH DECEMBER 2009, EQUIPPED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION, SHOULD THE "UP" SWITCH BE RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL AND MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.
Model years in this history: 2010, 2009, 2008, 2007
Consequence and remedy
Consequence
WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.
Remedy
GLAVAL BUS WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. A SOFTWARE SOLUTION FOR THIS SAFETY DEFECT IS UNDER INVESTIGATION. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON APRIL 26, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR GLAVAL BUS AT 1-800-322-2884.
09V42100010/28/2009
GLAVAL BUS IS RECALLING CERTAIN MODEL YEAR 2001 THROUGH 2009 TRANSIT BUSES EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.
Model years in this history: 2009, 2008, 2007, 2006, 2005, 2004, 2003, 2002, 2001
Consequence and remedy
Consequence
A SHORT COULD OCCUR, POSSIBLY CAUSING SMOKE AND FIRE.
Remedy
GLAVAL BUS WILL NOTIFY OWNERS AND LUMINATOR WILL REPAIR THE BUSES FREE OF CHARGE. PLEASE SEE LUMINATOR'S DEFECT REPORT 09E-054. THE SAFETY RECALL BEGAN ON NOVEMBER 10, 2009. OWNERS MAY CONTACT LUMINATOR AT 1-972-516-3033 OR GLAVAL BUS AT 1-574-262-2212.
09V40200010/15/2009
GLAVAL BUS IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 TRANSIT BUSES EQUIPPED WITH CARRIER K410 ROOFTOP CONDENSERS. INADEQUATE OVERCURRENT PROTECTION OF ONE OR MORE OF THE FANS IN THE K410 CONDENSER MAY CAUSE OVERHEATING OF THE FAN'S WIRES.
Model years in this history: 2009, 2008
Consequence and remedy
Consequence
OVERHEATING OF THE CONDENSER UNIT WIRES COULD RESULT IN A FIRE CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.
Remedy
GLAVAL BUS WILL NOTIFY OWNERS TO CONTACT AN AUTHORIZED CARRIER DEALER TO OBTAIN THE REMEDY. PLEASE ALSO SEE CARRIER'S DEFECT REPORT 09E-055. THE SAFETY RECALL BEGAN ON OCTOBER 28, 2009. OWNERS MAY CONTACT CARRIER AT 1-800-673-2431 OR GLAVAL BUS TOLL-FREE AT 1-800-450-2211.
09V21200006/09/2009
GLAVAL BUS IS RECALLING 45 MODEL YEAR 2008 AND 2009 TRANSIT BUSES MANUFACTURED BETWEEN JULY 1, 2008 AND JANUARY 31, 2009, EQUIPPED WITH CARRIER K410 ROOFTOP MOUNTED CONDENSERS. THE COVER OF THE CONDENSER ASSEMBLY MAY INTERFERE WITH THE COIL HEADER WHEN THE COVER IS PLACED ON THE UNIT ASSEMBLY. THE POTENTIAL INTERFERENCE PREVENTS THE COVER FROM RESTING ON THE UNIT MOUNTING SURFACE, CREATING A GAP BETWEEN THE COVER AND UNIT ASSEMBLY.
Model years in this history: 2009, 2008
Consequence and remedy
Consequence
THIS CONDITION WILL NOT PERMIT THE COVER FASTENERS TO SECURELY CLAMP THE COVER TO THE UNIT ASSEMBLY, WHICH MAY RESULT IN THE COVER DISLOCATING FROM THE UNIT DURING OPERATION, POSSIBLY CAUSING A CRASH OR CAUSE INJURY TO PEDESTRIANS.
Remedy
GLAVAL WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 14, 2009. OWNERS MAY CONTACT GLAVAL AT 1-800-333-0510 OR CARRIER AT 1-800-673-2431.
09V09400003/20/2009
ATLANTIC BUS SALES IS RECALLING 110 RICON WHEELCHAIR LIFTS WHICH IT INSTALLED ON MY 2006 AND 2007 ELDORADO AND GLAVAL TRANSIT BUSES. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Model years in this history: 2007, 2006
Consequence and remedy
Consequence
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy
ATLANTIC BUS SALES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR ATLANTIC BUS SALES AT 1-954-941-7722.
09V09500003/20/2009
ATLANTIC BUS SALES IS RECALLING 42 RICON WHEELCHAIR LIFTS WHICH IT INSTALLED ON CERTAIN MY 2006 AND 2007 ELDORADO AND GLAVAL TRANSIT BUSES. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Model years in this history: 2007, 2006
Consequence and remedy
Consequence
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy
ATLANTIC BUS SALES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR ATLANTIC BUS SALES AT 1-954-941-7722.
08V49300009/24/2008
GLAVAL BUS IS RECALLING 171MY 2005-2006 UNIVERSAL, PRIMETIME, TITAN, AND APOLLO TRANSIT AND SHUTTLE BUSES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Model years in this history: 2006, 2005
Consequence and remedy
Consequence
A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Remedy
GLAVAL BUS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-800-322-2884 OR GLAVAL BUS AT 1-574-262-2212.
08V01400001/20/2008
CERTAIN TRANSIT BUSES EQUIPPED WITH BRAUN PLATFORM LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." A PASSENGER CAN APPROACH THE EXPOSED LIFT DOORWAY WITHOUT THE AUDIBLE ALARM ALERTING THEM OF THEIR PROXIMITY TO THE THRESHOLD.
Model years in this history: 2007, 2006
Consequence and remedy
Consequence
SHOULD THE THRESHOLD WARNING SYSTEM FAIL TO OPERATE, THE LIFT USER CAN FALL FROM THE VEHICLE AND BE SERIOUSLY INJURED.
Remedy
GLAVAL IS WORKING WITH BRAUN CORPORATION TO HAVE THE DOORWAY LIFT FIXED FREE OF CHARGE (PLEASE SEE 06E094). OWNERS MAY CONTACT BRAUN CORPORATION AT 1-800-946-7513 OR GLAVAL AT 1-574-262-2212.
07V07200003/01/2007
CERTAIN BUSES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE INNER BARRIER INTERLOCK SWITCH SYSTEM IN THE LIFT BASEPLATE MAY NOT DETECT THE PRESENCE OF A PASSENGER (EITHER WHEELCHAIR OR STANDEE) ON THE BARRIER AND CAN ALLOW THE PLATFORM TO MOVE DOWN MORE THAN ONE INCH BELOW FLOOR LEVEL WHEN OCCUPIED.
Model years in this history: 2006
Consequence and remedy
Consequence
IN THE EVENT THIS CONDITION OCCURS DURING PASSENGER OPERATIONS, IT MAY BE POSSIBLE FOR THE WHEELCHAIR TO TIP BACKWARDS ONTO THE PLATFORM IF THE USER IS BACKING ONTO THE LIFT FROM INSIDE THE VEHICLE AND HAS THE SMALL FRONT WHEELS FULLY OR PARTIALLY ON THE INNER BARRIER WHEN THE PLATFORM WAS LOWERED. A PERSON STANDING COULD LOSE HIS OR HER BALANCE IF THEY WERE POSITIONED FULLY OR PARTLY ON THE INNER BARRIER WHEN THE PLATFORM WAS LOWERED. EITHER CONDITION COULD CAUSE PERSONAL INJURY.
Remedy
GLAVAL BUS IS WORKING WITH RICON TO REPAIR THESE WHEELCHAIR LIFTS (PLEASE SEE 06E101). OWNERS CAN CONTACT RICON AT 800-322-2884 OR GLAVAL BUS AT 574-262-2212.
06V32200008/31/2006
CERTAIN BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' AN INCORRECTLY LABELED WEIGHT STICKER WAS ATTACHED.
Model years in this history: 2005
Consequence and remedy
Consequence
THIS INFORMATION COULD POTENTIALLY RESULT IN CONSUMERS LOADING THEIR VEHICLES BEYOND THE GROSS VEHICLE WEIGHT RATING (GVWR).
Remedy
THE CAPACITY WILL BE REDUCED ON BOTH VEHICLES AND A NEW WEIGHT RATING LABEL WILL BE INSTALLED. BOTH VEHICLES HAVE BEEN TAKEN OUT OF SERVICE AND PARKED UNTIL REPAIRS HAVE BEEN MADE.
06V30400008/07/2006
CERTAIN TRANSIT BUSES, BUILT ON FORD, FREIGHTLINER, AND GENERAL MOTORS CHASSIS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, 'SEAT BELT ASSEMBLY ANCHORAGES.' THE SEATS EQUIPPED WITH SEAT BELTS MAY HAVE BEEN BOLTED TO THE BUS STRUCTURE INCORRECTLY.
Model years in this history: 2006
Consequence and remedy
Consequence
AN OCCUPANT NOT PROPERLY WEARING A SEAT BELT MAY HAVE AN INCREASED RISK OF INJURY DURING A CRASH.
Remedy
DEALERS WILL INSTALL THE NECESSARY PARTS TO CORRECTLY FASTEN THE SEATS TO THE BUS STRUCTURE FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 25, 2006. OWNERS MAY CONTACT GLAVAL BUS AT 1-800-445-2824.
06V19100006/05/2006
ON CERTAIN TRANSIT BUSES BUILT ON FORD E450 CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS, THE VERTICAL SUPPORT ARMS WERE IMPROPERLY WELDED.
Model years in this history: 2005
Consequence and remedy
Consequence
DURING PASSENGER OPERATIONS IT MAY NOT BE POSSIBLE TO CLOSE THE LIFT DOOR CAUSING THE VEHICLE INTERLOCKS TO REMAIN ENGAGED PREVENTING MOVEMENT OF THE BUSES OR THE ABILITY TO LOAD OR UNLOAD PASSENGERS WITH DISABILITIES FROM THE VEHICLE.
Remedy
RICON IS CONDUCTING THIS RECALL (PLEASE SEE 06E008000) AND WILL REPLACE THE TWO VERTICAL ARMS EVEN IF ONLY ONE ARM IS CRACKED FREE OF CHARGE. OWNERS MAY CONTACT GLAVAL BUS AT 574-262-2212 OR RICON AT 1-818-267-3000.
