NHTSA lists 25 model-level recall records for this year, make, and model. These records may apply to your vehicle; confirm your specific VIN with NHTSA or the manufacturer.
Recall records
Service brakes, hydraulic: Pedals and linkages12/01/200909V461000
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES BUILT ON FCCC B2 CHASSIS MANUFACTURED FROM OCTOBER 15, 2004 THROUGH NOVEMBER 25, 2009, EQUIPPED WITH KONGSBERG AUTOMOTIVE ADJUSTABLE BRAKE PEDALS. THE ADJUSTABLE BRAKE PEDAL ARM MAY LOOSEN ALLOWING THE ARM TO ROTATE AROUND ITS SHAFT AND SWING IN FRONT OF THE ACCELERATOR PEDAL, REDUCING BRAKING FUNCTION.
Consequence
A LOOSE BRAKE PEDAL INCREASES THE RISK OF A CRASH.
Remedy
DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 22, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS WARRANTY CLAIMS DEPARTMENT AT 1-800-547-0712.
DAIMLER TRUCKS' CAMPAIGN NUMBER IS FL-569.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
DAIMLER TRUCKS IS RECALLING 15,686 MY 2005 THROUGH 2009 FCCC AND THOMAS BUILT SCHOOL AND TRANSIT BUSES MANUFACTURED BETWEEN MARCH 2005 AND MAY 2008 EQUIPPED WITH A CERTAIN BRAKE LAMP AIR PRESSURE SWITCH. THE CONTACTS IN THE PRESSURE SWITCH FOR THE LOW CURRENT BRAKE LAMP SIGNAL TO THE CHASSIS ECU MAY HAVE BECOME CONTAMINATED BY SILICONE DURING ASSEMBLY CAUSING INSULATING DEPOSITS TO BUILD UP OVER TIME PREVENTING THE BRAKE LAMPS FROM OPERATING.
Consequence
INOPERATIVE BRAKE LAMPS WOULD NOT PROVIDE A SIGNAL TO FOLLOWING DRIVERS THAT THE BRAKES ARE APPLIED AND A CRASH MAY OCCUR.
Remedy
DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE PRESSURE SWITCH FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 18, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712 OR THOMAS BUILT BUSES AT 1-336-889-4871.
DAIMLER TRUCKS' RECALL NO. FL-538.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Electrical system10/18/201111V503000
DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED FROM APRIL 5, 2004 THROUGH DECEMBER 26, 2005. THE PASS-THROUGH POWER CABLE CONNECTIONS LOCATED BEHIND THE DRIVER'S SIDE KICK PANEL MAY CORRODE POTENTIALLY RESULTING IN AN ELECTRIC FAULT OR SHORT CIRCUIT.
Consequence
AN ELECTRIC FAULT OR SHORT CIRCUIT OF AN UN-FUSED POWER CABLE MAY RESULT IN A VEHICLE FIRE.
Remedy
THE FINAL REMEDY IS BEING DEVELOPED. DTNA WILL SEND OWNERS AN INTERIM NOTICE ADVISING THEM TO INSPECT THEIR BUSES FOR CORROSION IN THE AREA OF THE POWER TERMINALS, AND IF EXCESSIVE CORROSION IS FOUND, TO TAKE THEIR VEHICLE TO AN AUTHORIZED SERVICE FACILITY. REPAIRS WILL BE MADE BY DTNA FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 15, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
DTNA'S RECALL CAMPAIGN NUMBER IS FL-616.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Service brakes, hydraulic10/18/201111V505000
DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2009 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED FROM MARCH 9, 2004, THROUGH JANUARY 2, 2008, EQUIPPED WITH CATERPILLAR C7 ENGINES, HYDRAULIC BRAKES, AND A FUEL WATER SEPARATOR. THE FUEL LINE GOING FROM THE FUEL WATER SEPARATOR TO THE ENGINE MAY RUB ON THE HYDRAULIC BRAKE LINES POTENTIALLY RESULTING IN BRAKE FLUID LEAK.
Consequence
A BRAKE FLUID LEAK MAY REDUCE BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
Remedy
DTNA WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE VEHICLES TO ENSURE THAT THERE IS THE CORRECT CLEARANCE BETWEEN THE FUEL AND BRAKE LINES. DAMAGED LINES WILL BE REPLACED. REPAIRS WILL BE MADE BY DTNA AUTHORIZED SERVICE FACILITIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 27, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
DTNA'S RECALL CAMPAIGN NUMBER IS FL-615.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Structure09/21/200707V459000
CERTAIN THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN MARCH 8, 2006, AND AUGUST 10, 2007, EQUIPPED WITH ONE OR MORE "PRO LO ROOF HATCH" OPTION NUMBERS D107307001, D107307002, OR D107307003. RETROREFLECTIVE TAPE WAS NOT INSTALLED AROUND THE PERIMETER OF THE ROOF MOUNTED EMERGENCY EXIT HATCH. THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE.
Consequence
IMPROPERLY IDENTIFIED EMERGENCY EXITS MAY HINDER EVACUATION EFFORTS.
Remedy
THOMAS BUILT WILL NOTIFY OWNERS AND REPAIR THE BUSES BY INSTALLING RETROREFLECTIVE TAPE FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 4, 2007. OWNERS MAY CALL THOMAS BUILT AT 336-889-4871 OR CONTACT FREIGHTLINER AT 800-547-0712.
FREIGHTLINER RECALL NO. FL-510.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Equipment adaptive/mobility09/04/201515V565000
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2006-2015 Thomas Built Buses FS-65, Saf-T-Liner C2, Saf-T-Liner EF, Saf-T-Liner EFX, Saf-T-Liner HDX, and Minotour DRW school buses manufactured January 3, 2006, to August 1, 2014, and equipped with certain Ricon model S2005, S2010, S5005, S5010, S5505, S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence
If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Remedy
DTNA will notify owners, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began onNovember 2, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-686.
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Engine and engine cooling07/27/201010V340000
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 FCCC B2 106 CH AND THOMAS BUILT SAF-T-LINER C2 AND HDX SCHOOL BUSES MANUFACTURED FROM SEPTEMBER 5, 2006 THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE900 EPA04 AND EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL DUE TO EXCESSIVE INTERNAL TEMPERATURES.
Consequence
A SHORT CIRCUITED GRID HEATER COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.
Remedy
DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JULY 29, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
DAIMLER TRUCKS' RECALL CAMPAIGN NUMBER IS 10C-5.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Steering07/18/200707V306000
FREIGHTLINER IS RECALLING CERTAIN SCHOOL BUS CHASSIS, HEAVY TRUCKS, VAN CHASSIS, RV MOTORHOME CHASSIS MANUFACTURED FROM JANUARY 5 TO MAY 17, 2007, EQUIPPED WITH AXLE ALLIANCE COMPANY (AAC) FRONT AXLES. DURING THE FRONT AXLE ASSEMBLY, THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE OVER OR UNDER TIGHTENED.
Consequence
INCORRECTLY TIGHTENED STEERING ARM FASTENERS MAY FATIGUE AND FRACTURE WHICH COULD CAUSE A CRASH WITHOUT WARNING.
Remedy
THOMAS BUILT WILL NOTIFY OWNERS, INSPECT THE FASTENERS, AND REPLACE THE STEERING ARM IF NECESSARY. THE RECALL BEGAN ON DECEMBER 21, 2007. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
FREIGHTLINER RECALL NO. FL-501.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Equipment07/17/201717V454000
Daimler Trucks North America LLC (DTNA) is recalling certain 2005-2018 Thomas Built Buses Saf-T-Liner C2 transit buses. In the event of a crash, the wheelchair pocket track anchorage may not adequately secure a the wheelchair.
Consequence
In the event of a crash, an unsecured wheelchair may increase the risk of injury.
Remedy
DTNA will notify owners, and dealers will add additional fasteners to the wheelchair pocket track to reinforce the anchorage, free of charge. An interim letter was mailed on September 13, 2017. The recall began on December 20, 2017. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-743.
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Equipment07/17/201717V453000
Daimler Trucks North America LLC (DTNA) is recalling certain 2005-2018 Thomas Built Buses Saf-T-Liner C2 school buses. In the event of a crash, the wheelchair pocket track anchorage may not adequately secure a the wheelchair.
Consequence
In the event of a crash, an unsecured wheelchair may increase the risk of injury.
Remedy
DTNA will notify owners, and dealers will add additional fasteners to the wheelchair pocket track to reinforce the anchorage, free of charge. An interim notice was sent to owners on September 13, 2017. The recall began on December 20, 2017. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-743.
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Service brakes, air: Supply: Check valve07/16/200707V302000
CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.
Consequence
THESE CONDITIONS COULD EITHER RESULT IN LEAKAGE AND CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKE WITHOUT WARNING OR POSSIBLY LEAD TO UNINTENDED VEHICLE ROLLAWAY OR BRAKE DRAG WHICH COULD RESULT IN A VEHICLE CRASH, PERSONAL INJURY, OR DEATH.
Remedy
FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 11, 2008 TO FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS OWNERS; TO THOMAS BUILT BUS OWNERS ON FEBRUARY 1, 2008. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
FREIGHTLINER RECALL NO. FL-504.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Structure: Body: Door07/07/201515V432000
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2002-2013 Thomas Built Buses Saf-T-Liner ER, 2001-2005 Saf-T-Liner Conventional, 2002-2013 Saf-T-Liner MVP-EF, 2013 Saf-T-Liner EFX, 2001-2008 Saf-T-Liner FS65, 2005-2013 Saf-T-Liner C2, 2003-2013 Saf-T-Liner HDX, 2002-2003 Saf-T-Liner MVP-ER, 2002 Vista, and 2002-2003 TL-960 school buses manufactured from February 5, 2001, through May 29, 2012. In the affected vehicles, the stem that connects the outside emergency door handle to the emergency door opening mechanism may corrode.
Consequence
If the stem corrodes, the door handle could detach from the emergency door opening mechanism, delaying the opening of the door and the evacuation of the bus. In the event of an emergency, this may increase the risk of injury to the bus occupants.
Remedy
DTNA will notify owners, and dealers will either replace the stems or protect them against corrosion, free of charge. Daimler issued an interim notification to owners on August 25, 2015. The recall began on December 24, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-685.
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Structure: Body: Door07/06/201515V425000
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2002-2004 Thomas Built Buses Saf-T-Liner ER, 2001-2005 Saf-T-Liner Conventional, 2002-2013 Saf-T-Liner MVP-EF, 2013 Saf-T-Liner EFX, 2001-2008 Saf-T-Liner FS65, 2005-2013 Saf-T-Liner C2, 2003-2013 Saf-T-Liner HDX, 2002-2003 Saf-T-Liner MVP-ER, 2002 Vista, and 2002-2003 TL-960 non-school buses. In the affected vehicles, the stem that connects the outside emergency door handle to the emergency door opening mechanism may corrode.
Consequence
If the stem corrodes, the door handle could detach from the emergency door opening mechanism, delaying the opening of the door and the evacuation of the bus. In the event of an emergency, this may increase the risk of injury to the bus occupants.
Remedy
DTNA will notify owners, and dealers will either replace the stems or protect them against corrosion, free of charge. An interim notice was mailed to owners on August 28, 2015. The recall began on December 24, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-685.
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Fuel system, other: Delivery06/13/200707V250000
CERTAIN MY 2005-2007 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED BETWEEN DECEMBER 1, 2003, AND OCTOBER 10, 2006. FASTENERS USED TO SECURE THE FUEL TUBE MOUNTING BRACKET TO THE BUS FLOOR MAY BE MISSING OR IMPROPERLY INSTALLED. VEHICLES WITH MISSING OR IMPROPERLY INSTALLED FUEL FILL TUBE MOUNTING BRACKET FASTENERS DO NOT COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY."
Consequence
THIS COULD RESULT IN FUEL SPILLAGE DURING OR AFTER A VEHICLE CRASH POSSIBLY RESULTING IN A FIRE.
Remedy
FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 10, 2007. OWNERS CAN CONTACT THOMAS BUILT AT 336-889-4871 OR CONTACT FREIGHTLINER AT 800-547-0712.
FREIGHTLINER RECALL NO. FL-498.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Exterior lighting05/18/200707V212000
CERTAIN 2005 THROUGH 2008 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED FROM DECEMBER 1, 2003 TO MAY 18, 2007. THE EXTERNAL WARNING LIGHTS MAY STOP FUNCTIONING UNEXPECTEDLY IF THE FRONT ENTRANCE DOOR CLOSES WITHOUT THE DRIVER'S INPUT.
Consequence
FAILURE OF THE EXTERNAL WARNING LIGHTS TO REMAIN ON DURING THE LOADING OR UNLOADING PROCESS COULD POSSIBLY RESULT IN A STUDENT BEING STRUCK BY A PASSING MOTORIST WHILE BOARDING OR EXITING THE BUS.
Remedy
FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 21, 2008. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871 OR CONTACT FREIGHTLINER AT 800-547-0712.
FREIGHTLINER RECALL NO. FL-496.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Equipment adaptive/mobility05/17/201212V226000
DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 SAF-T-LINER EF, MINOTOUR, SAF-T-LINER C2, SAF-T-LINER HDX TRANSIT BUSES EQUIPPED WITH BRAUN CENTURY-2 AND VISTA-2 WHEELCHAIR LIFTS. OVER TIME, AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED.
Consequence
A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIRÂ’S OCCUPANT COULD FALL AND SUSTAIN INJURY.
Remedy
DTNA WILL NOTIFY OWNERS, AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED BRAUN DEALERS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 28, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
DTNA'S RECALL CAMPAIGN NUMBER IS FL-627.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Equipment adaptive/mobility05/17/201212V225000
DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 SAF-T-LINER EF, MINOTOUR, SAF-T-LINER C2, AND SAF-T-LINER HDX SCHOOL BUSES EQUIPPED WITH BRAUN CENTURY-2 AND VISTA-2 WHEELCHAIR LIFTS. OVER TIME, AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED.
Consequence
A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIRÂ’S OCCUPANT COULD FALL AND SUSTAIN INJURY.
Remedy
DTNA WILL NOTIFY OWNERS, AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED BRAUN DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 28, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
DTNA'S RECALL CAMPAIGN NUMBER IS FL-627.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
DTNA IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2011 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED BEGINNING JANUARY 19, 2005 THROUGH APRIL 16, 2010. THE STOP LAMPS MAY BE INTERMITTENT DURING LIGHT BRAKE APPLICATIONS.
Consequence
THE STOP LAMPS MAY NOT PROPERLY INDICATE THAT THE SERVICE BRAKES ARE APPLIED WHICH MAY LEAD TO A CRASH WITHOUT WARNING.
Remedy
DTNA WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DTNA DEALERSHIPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
DTNA'S RECALL CAMPAIGN NUMBER IS FL-577.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Equipment: Appliance: Air conditioner04/06/201111V222000
DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 SAF-T-LINER C2, SAF-T-LINER HDX, MVP-EF, FS-65, AND MINOTOR SCHOOL BUSES MANUFACTURED FROM JANUARY 2, 2006, THROUGH JANUARY 31, 2011, EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.
Consequence
IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND A VEHICLE FIRE MAY OCCUR.
Remedy
DTNA WILL NOTIFY OWNERS AND PROVIDE INFORMATION ON HOW TO OBTAIN THE RETROFIT KIT FROM CARRIER ALONG WITH REPAIR INSTRUCTIONS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 20, 2011. (SEE CARRIER'S RECALL CAMPAIGN 11E-003.) OWNERS MAY CONTACT CARRIER AT 1-800-793-4741 OR DTNA AT 1-800-547-0712.
DTNA'S RECALL CAMPAIGN NUMBER IS FL-604.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Equipment: Other: Labels03/31/201111V201000
CERTAIN MODEL YEAR 2000 THROUGH 2009 THOMAS BUILT SCHOOL BUSES MANUFACTURED FROM APRIL 17, 2000, THROUGH DECEMBER 21, 2009, WERE EQUIPPED WITH AN INCORRECT TIRE LOAD CERTIFICATION LABEL. THE CERTIFICATION LABELS LIST "D" LOAD RANGE TIRES WITH A RECOMMENDED COLD TIRE INFLATION PRESSURE GREATER THAN 65 PSI. THE BUSES ARE EQUIPPED WITH LOAD RANGE "E" TIRES THAT REQUIRE A HIGHER MINIMUM TIRE PRESSURE. ACCORDINGLY, THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence
INCORRECT TIRE INFORMATION MAY LEAD TO VEHICLE OVERLOADING THAT CAN RESULT IN A TIRE FAILURE WHICH MAY LEAD TO A VEHICLE CRASH.
Remedy
DTNA WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE INCORRECT LABEL WITH A CORRECT LABEL FREE OF CHARGE OR, IF THE OWNER WISHES, THEY MAY REPLACE THE LABEL THEMSELVES. OWNERS SHOULD CONTACT DTNA AT 1-800-547-0712 OR THOMAS BUILT AT 1-336-889-4871 TO OBTAIN THE LABEL IF THEY WISH TO AFFIX IT THEMSELVES. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 28, 2011.
DTNA'S RECALL CAMPAIGN NUMBER IS FL-601.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Structure: Body: Door: Hinge and attachments02/26/200808V087000
DAIMLER TRUCKS IS RECALLING 243,435 MY 1995-2008 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 1994, AND MARCH 10, 2008. (ADDITIONAL BUSES HAVE BEEN ADDED TO THIS RECALL CAMPAIGN. PLEASE SEE SUPPLEMENTAL REPORT NO. 4) THE EMERGENCY EXIT DOOR HANDLE BEGINS CORRODING AROUND THE SECURING ROLL PIN AND SQUARE DRIVE MECHANISM CAUSING THE PROTECTIVE FINISH TO CHIP AND FLAKE. CONTINUED CORROSION AND PITTING WEAKENS THE HANDLE. HANDLES WEAKENED BY CORROSION MAY BREAK WHILE TRYING TO OPEN THE DOOR FROM THE EXTERIOR.
Consequence
IN THE EVENT OF AN EMERGENCY, A PERSON ON THE OUTSIDE OF THE BUS MAY BREAK THE DOOR HANDLE TRYING TO OPEN THE EMERGENCY EXIT POTENTIALLY DELAYING EVACUATION AND INCREASING THE RISK OF PERSONAL INJURY TO THE VEHICLE'S OCCUPANTS.
Remedy
DAIMLER TRUCKS WILL NOTIFY OWNERS AND WILL REPLACE THE HANDLES WITH A MORE ROBUST HANDLE FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY THOMAS BUILT BUSES DEALERSHIPS. THE RECALL BEGAN ON AUGUST 18, 2008, AND NOTIFICATION FOR THE REVISED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT APRIL 29, 2009. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.
DAIMLER TRUCKS RECALL NO. FL-525.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Equipment adaptive/mobility02/26/200808V088000
DAIMLER TRUCKS IS RECALLING 760 MY 2003-2007 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 6, 2005 AND JULY 19, 2006, EQUIPPED WITH BRAUN WHEELCHAIR LIFTS, MODELS NL, NCL, OR NVL. THE THRESHOLD WARNING SYSTEMS OF THE SUBJECT MODEL WHEELCHAIR LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES.
Consequence
SHOULD THE THRESHOLD WARNING SYSTEM FAIL TO OPERATE, THE LIFT USER CAN FALL FROM THE VEHICLE AND BE SERIOUSLY INJURED.
Remedy
DAIMLER TRUCKS WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY WHICH WILL BE PERFORMED BY THOMAS BUILT DEALERSHIPS. THE RECALL BEGAN ON AUGUST 8, 2008. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.
DAIMLER TRUCKS RECALL NO. FL-524.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Service brakes, air02/13/200707V055000
CERTAIN MY 2007 THOMAS BUILT C2 SAF-T-LINER SCHOOL BUSES AND FREIGHTLINER BUSINESS CLASS M2, FCCC B2, AND S2 BUS CHASSIS MANUFACTURED BETWEEN JULY 3 AND NOVEMBER 3, 2006.
Consequence
UNDER CERTAIN CONDITIONS, THE PARK BRAKE OR WORK BRAKE MAY FAIL ALLOWING THE VEHICLE TO ROLL, POSSIBLY RESULTING IN PERSONAL INJURY. ALSO, THE STOP LAMPS MAY INTERMITTENTLY FAIL TO ILLUMINATE WHEN THE SERVICE BRAKE IS APPLIED.
Remedy
FREIGHTLINER WILL NOTIFY OWNER AND REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN ON MAY 24, 2007. OWNERS CAN CONTACT FREIGHTLINER'S CUSTOMER ASSISTANCE CENTER AT 800-385-4357.
FREIGHTLINER'S RECALL NO. FL-491.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Equipment01/30/201818V083000
Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner HDX, FS65, and Minotour school buses, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy
DTNA will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall is expected to begin March 30, 2018. Owners may contact DTNA customer service at 1-800-547-0712 or Kidde customer service at 1-855-262-3540 or online at www.kidde.com and click on "Product Safety Recall" for more information. DTNA's number for this recall is FL-759.
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
Structure: Body: Door: Hinge and attachments01/08/200909V010000
DAIMLER TRUCKS IS RECALLING 22,206 THOMAS BUILT MY 2005 THROUGH 2010 SCHOOL BUSES MANUFACTURED FROM OCTOBER 2004 THROUGH NOVEMBER 24, 2008. THE LOWER END OF THE FRONT ENTRANCE DOOR AFT ASSIST HANDRAIL MAY BE LOCATED TOO CLOSE TO THE STEP.
Consequence
IT MAY BE POSSIBLE FOR ITEMS SUCH AS DRAWSTRINGS AND STRAPS TO BECOME CAUGHT ON THE HANDRAILS POTENTIALLY LEADING TO INJURY OR DEATH.
Remedy
DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY THOMAS BUILT BUSES DEALERSHIPS AND DIRECT WARRANTY CUSTOMER FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 6, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
DAIMLER TRUCKS' RECALL NO. FL-543.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Your record
What is the status for your vehicle?
Check your exact VIN before marking whether this recall applies.
Saved only in this browser. Recall You Later does not receive this information.
